2016 Subaru Outback

2016 Subaru Outback recalls (4)

• AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

  Subaru of America, Inc. (Subaru) is recalling certain 2016-2017 Outback vehicles. A replacement air bag control module may have been installed that is not compatible with the passenger air bag module, possibly affecting air bag deployment.

  Remedy: Subaru will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began February 3, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUX-09.

• STEERING:COLUMN

  Subaru of America, Inc. (Subaru) is recalling certain model year 2016-2017 Legacy and Outback vehicles manufactured February 29, 2016, to May 6, 2016. The steering column on the affected vehicles may have been improperly machined, and as a result, turning the steering wheel may have no effect on the direction of the wheels.

  Remedy: Subaru will notify owners, and dealers will inspect the lot number on the steering column, replacing the steering column, as necessary, free of charge. The recall began May 13, 2016. Owners may contact Subaru customer service at 1-800-782-2783 or by visiting http://www.wtd65.service-campaign.com. Subaru's number for this recall is WTD-65. Note: Until the vehicles have been inspected, owners are advised not to drive their vehicles.

• POWER TRAIN:DRIVELINE:DRIVESHAFT

  Subaru of America, Inc. (Subaru) is recalling certain 2015 and 2016 model year Subaru Legacy 4-Door and Outback vehicles manufactured July 3, 2015, to July 27, 2015. Transmission oil may leak from a deformed seal cap on the propeller shaft yoke.

  Remedy: Subaru will notify owners, and dealers will replace the propeller shaft, free of charge. The recall began on August 28, 2015. Owners may contact 1-800-782-2783. Subaru's number for this recall is WQU-56.

• POWER TRAIN:DRIVELINE:DRIVESHAFT

  Subaru of America, Inc. (Subaru) is recalling certain model year 2016 Legacy vehicles manufactured October 24, 2015, to November 16, 2015, and Outback vehicles manufactured October 24, 2015, to November 17, 2015. Due to the improper tightening of the securing nuts, the drive shaft may separate from the rear differential.

  Remedy: Subaru has notified owners, and dealers will inspect the fastening nuts, and tighten or replace them, as necessary, free of charge. The recall began on December 10, 2015. Owners may contact Subaru customer service at 1-856-488-8500. Subaru's number for this recall is WQV-57.

2016 Subaru Outback safety ratings

Source: NHTSA NCAP ratings.

2016 Subaru Outback owner complaints (15)

• ELECTRICAL SYSTEM

  The reporting citizen was driving legally on [XXX] going forward towards the parking lot next to the round about when an uncrewed, autonomous commercial vehicle operated by Waymo suffered a catastrophic software/hardware failure. The 6,000-pound driverless robot taxi aggressively pursued and chased the citizen’s vehicle in reverse for that full city block despite honking the horn and then holding it down the entire time as the killing 6,000 lbs robot car kept reversing towards the citizens car instead of going forward, forcing the citizen out into a perpendicular intersecting road onto [XXX] The citizen safely evaded a severe collision solely through high-speed defensive driving, reversing, and holding down the horn to warn surrounding motorists of the out-of-control vehicle. The autonomous system failed to stop, recognize the citizen's vehicle, or register the horn. Upon reviewing the internal vehicle data and footage, Waymo’s corporate office confirmed to the citizen on several calls after the [XXX] reporting that this specific vehicle "went rogue." Waymo admitted the failure was severe enough that they immediately pulled the specific vehicle out of operational service. I have several case #s from Waymo of each call admitting fault. These 6000 lbs killing car robots are NOT SAFE and should not be allowed on public roads where real humans are driving! I can’t sleep since [XXX] due to the nightmares of these killing car robots trying to kill me. I must factor in extra time to go anywhere as I cannot have these killing car robots near me and they are everywhere in my area. I visibly shake and sweat involuntarily whenever I see one of these even from very far away or even think about them—which is pretty much always now since [XXX]. Because Waymo deployed a malfunctioning 6,000-pound autonomous vehicle that aggressively chased a resident on public streets, this is an immediate Public Safety Hazard and Reckless Endangerment issue caused by Waymo. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• POWER TRAIN

  While driving the 2016 Subaru Outback, the vehicle experienced a sudden, catastrophic failure of the Continuously Variable Transmission (CVT). The transmission completely failed, resulting in an immediate and dangerous loss of propulsion while operating the vehicle. This created an immediate safety hazard for myself, my toddler and other drivers on the road, as the vehicle could no longer maintain speed or accelerate safely to clear traffic. A certified repair facility diagnosed the issue as a complete internal mechanical failure of the transmission, requiring a total replacement at an estimated cost of roughly $11,000. This generation of Subaru CVTs has a well-documented history of premature, catastrophic mechanical failure, which Subaru of America has previously acknowledged via past warranty extensions. The sudden loss of power caused by this engineering defect poses a severe and ongoing safety risk to consumers. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• STEERING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL

  SUBJECT: Formal Safety Defect Complaint: 2016 Subaru Outback – Manufacturing Nondisclosure of Latent "Day 1" Design Flaw Causing Ignition Key Entrapment, Uncommanded Steering Column Lockout, and Severe Family Safety Risk I am writing to formally report a severe, unaddressed safety defect and a deceptive corporate practice by Subaru of America, Inc. affecting my 2016 Subaru Outback. This vehicle suffers from a "Day 1" latent engineering flaw that causes the physical ignition key to become permanently trapped in the ignition cylinder, triggering an uncommanded, rigid locking of the steering column assembly. Subaru has possessed documented knowledge of this failure for years, cataloging it under Technical Service Bulletin TSB 16-112-18R. Rather than fulfilling its statutory obligation to issue a comprehensive federal safety recall, Subaru deployed a voluntary, time-bound 8-year warranty extension. Subaru conveniently did not notify me of this warranty extension. By doing so, the manufacturer unconscionably ignored this defect, placing its customers at direct peril. They capitalized on asymmetric information to shift both the financial burden and the severe physical safety risks of a known factory flaw onto my family, the moment an arbitrary time threshold expired. My family and I have been at active, continuous risk in this vehicle since the day we purchased it due to an engineering error that was present when the car rolled off the assembly line. The root cause of this failure is a fundamental engineering defect within the Continuously Variable Transmission (CVT) shifter assembly, specifically, the premature degradation of the electrical contacts within the select lever park-range switch.

• UNKNOWN OR OTHER

  Vehicle: 2016 Subaru Outback Recall Number: WUJ95 – Front Exhaust Pipe Bellows Crack I incurred repair expenses to address a condition that was later covered by Subaru Recall WUJ95. At the time of the repair, I was unaware that the vehicle was subject to this recall because I never received any recall notification from Subaru. The affected component was the front exhaust pipe bellows assembly covered by Recall WUJ95. The repair was completed by an independent repair facility. The condition involved a cracked exhaust bellows assembly. The failure of this component allowed exhaust gases to escape from the exhaust system into the cabin and is the condition identified by Subaru in Recall WUJ95. The issue was diagnosed and repaired by an independent repair facility. The repair addressed the same component and condition that was subsequently identified by Subaru as part of Recall WUJ95. After learning of the recall, I contacted Subaru of America seeking reimbursement because the repair was completed after the recall had been issued. Subaru denied reimbursement and stated that repairs performed at third-party facilities are not eligible. During the reimbursement review process, I requested documentation showing when and how recall notification was sent to me, including the address used, mailing date, and method of notification. Subaru declined to provide this information. Subaru also declined to provide the specific guidelines relied upon in denying reimbursement. My concern is that I never received recall notification before obtaining the repair, which prevented me from having the recall performed through an authorized Subaru retailer. I am requesting that NHTSA review whether recall notification requirements were properly satisfied in this case and whether vehicle owners are being provided sufficient information to verify recall notification when reimbursement requests are denied.

• SERVICE BRAKES

  On 05/08/2026 the brakes failed while in a queue at a drive-up restaurant. The car was steered away to a flat part of the parking lot. After a restart the brakes returned to operation and the car was taken to the dealership where the brake line were flushed and the brake fluid replaced. On 05/25/2026 the brakes failed after backing out of an inclined parking space in a parking garage. The car came to a stop when it backed into a concrete wall. The car was towed to the dealer. The dealer inspected inspected the car and reported that the brakes were working as they should.

• ELECTRICAL SYSTEM

  Parasitic battery drain due to a faulty DCM module. I've purchase 3 batteries in the past 16 months. I now have to keep a trickle charger on my car at night to ensure my battery is not dead in the morning. Unable to park overnight without charger due to fear of another dead battery.

• ELECTRICAL SYSTEM

  The DCM (Data Communication Module), also referred to as the Starlink telematics module, has failed. This failure is causing a continuous parasitic battery drain, which rapidly depletes the vehicle’s battery even after charging or replacement. The component remains installed in the vehicle and is available for inspection upon request. The failure has resulted in repeated battery drain and loss of vehicle operability. I have experienced a dead battery approximately 4–6 times between September 2025 and present, and the condition has worsened to the point where the vehicle cannot remain running or operable without the battery dying within approximately 5 minutes. This creates a safety risk because the vehicle can become inoperable without warning, increasing the likelihood of being stranded in unsafe conditions or unable to use the vehicle in an emergency. Yes, the issue has been diagnosed and confirmed by a Subaru dealership, which identified the DCM module as failed and requiring replacement. The failure is consistent with a parasitic battery drain caused by the DCM. The vehicle has been inspected by an authorized Subaru dealership.I have also contacted Subaru of America and opened a case requesting assistance with the repair. The primary symptom was repeated battery drain and failure to start beginning around September 2025. The issue progressed over time, with multiple instances of a dead battery, and has now worsened to the point where the battery drains within minutes, preventing normal vehicle operation. There were no consistent warning lights directly identifying the DCM as the cause prior to diagnosis.

• ENGINE

  leak in cam carrier gasket caused large ammounts of smoke to fill engine bay and enter cabin air system. Struggled to breath and vision to an extent was obstructed. when car was parked, smoke continued to fill the engine bay. problem was confirmed by an independent technitian, with the vehicle undergoing a complete inspection about a year ago from the dealership of purchase. no warning lamps turned on until enough oil had seeped from the leak in the liquid silicon gasket, at which point the low oil warning light had turned on.

• POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM

  My 2016 Subaru Outback CVT transmission has exhibited an intermittent jerking and grabbing sensation when accelerating from a stop, worse when cold, since at least February 2023. This is a known defect covered under Subaru warranty extension bulletin 16-115-18. February 2023 — An authorized Subaru dealer documented the complaint in writing. The technician stated the vehicle never warmed up during the test drive and dismissed the concern. The CVT issue was never repaired. I was never informed of Subaru's CVT warranty extension program. February 17 2026 — seven days before my warranty expiration — the same authorized Subaru dealer physically identified and documented a CVT oil pump cover leak. The same jerking complaint was again documented in writing. No repairs were made and the warranty expired one week later. The CVT defect has been physically confirmed by an authorized Subaru dealer within the warranty period and Subaru of America has denied my warranty claim in writing. This issue presents a safety concern. The unpredictable jerking and hesitation when accelerating from a stop creates dangerous situations in traffic, particularly at intersections and when merging. The vehicle is available for inspection upon request. Subaru chose to handle this known widespread defect as a quiet warranty extension rather than a mandatory recall despite hundreds of owners reporting identical symptoms.

• ENGINE

  My 2016 Outback 2.5L model experienced an exhaust noise and/or odor coming from cracks at the bellows section of the front exhaust pipe which includes the catalytic converter. It was diagnosed as leak occurring at the front exhaust pipe. Quoted repair for replacement part only is $2700 plus $1000 labor to repair. Upon investigation, it was discovered that Subaru Recall WUJ-95 with subject Exhaust Pipe Front (EPF) Bellows Cracking was issued in 2020. My specific VIN was excluded from this recall but I have experienced the exact issue described in the recall. As a result of this situation and exhaust inhalation the car is not able to be driven, this cause breathing issues for me, my wife and our 9 month old baby.

• STEERING

  Brake light comes on while driving and power steering also locks up..

• AIR BAGS

  Almost after I took ownership of my vehicle in August 2024 from Lexus of Pembroke Pines, I noticed a light on the dashboard that would light intermittently. I purchased an extended warranty for almost four thousand dollars at the time of sale, thank God, as this car has needed a lot of work that I was never told about nor was anything in the CARFAX indicating so many issues. Subaru of Pembroke Pines service department took vehicle in to work on the air bag sensor as that is what seemed to be the issue. In the sixteen months that I have been paying off a loan, the car has been in service for at least a combined ten months plus. They have changed the sensor twice and have changed the harness twice to no avail and that has been covered by the warranty. Now Subaru wants to take apart the car to trace wires to try to find out why the light still won't go out. The warranty company is refusing to take responsibility for the payment for the work and I cannot and will not pay out of my pocket. Subaru wants me to take my car back and drive it. I DO NOT WANT TO DIE FROM A FAULTY AIRBAG. There is something grossly wrong with the vehicle, the service department and especially the warranty company. Please help me get my vehicle fixed without having to be further raped financially. Subaru is trying to get me to purchase yet another vehicle AND I was told by the service lane manager that I should never have been sold that car. IT IS DANGEROUS. My files you are requesting are in my car which is at the dealership.

• ELECTRICAL SYSTEM

  I purchased a replacement battery in 2023. In August of 2025, the battery died, requiring a jump start. A local auto parts store checked the battery and it tested within acceptable limits, showing around 513 amps. A private shop confirmed this, and cleaned the battery terminals and cables. The battery functioned well until around November 2025, when it again died requiring a jump start. The battery again died in December 2025, about one month later, requiring a jump start.

• VISIBILITY/WIPER

  1.Windshield crack in the deicing area. Driving on a highway heard a loud boom as if a very big rock hit the car. 30-40 second later there was another boom of normal loudness. At this moment windshield crack has been noticed. The windshield will not be available, replacing it on 12/22/2025 2. Visibility has been affected 3. No, problem was not reproduced. Dealer representative said that the problem is not covered by Subaru. 4. Windshield was visually inspected by the dealership representative. I will try to collect more data at the windshield replacement shop. 5. There were no symptoms of the problem. N.B - the crack outside is flat, as if no rock hit happened. - I have camera's MP4, where sounds can be heard, 1GB

• ELECTRICAL SYSTEM

  The contact owns a 2016 Subaru Outback. The contact stated that the horn was inoperable. The vehicle was taken to the local dealer for a routine recall repair, and it was diagnosed and determined that the steering roll connector/clock spring had short-circuited. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 50,000.