2016 Audi A6

2016 Audi A6 recalls (3)

• FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL

  Volkswagen Group of America, Inc. (Audi) is recalling certain 2016-2018 Q7, A6 and A7 vehicles, and 2015-2018 Audi A8 vehicles. The left and right fuel rails may leak fuel.

  Remedy: Audi has notified owners, and dealers will replace the left and right fuel rail, free of charge. The recall began February 28, 2019. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 24DP.

• ELECTRICAL SYSTEM:WIRING

  Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2016 Audi A6 Sedans and 2015 Audi A7 vehicles. The auxiliary heater electrical connector on these vehicles may have been incorrectly inserted into the auxiliary heater, possibly resulting in increased electrical resistance.

  Remedy: Volkswagen will notify owners, and dealers will inspect the auxiliary heater connector, replacing the auxiliary heater and connector, as necessary, free of charge. The recall began March 15, 2019. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 82C1.

• AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

  Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2018 Audi S6 and S7, 2012-2018 A7 and A6 Sedan, and 2014-2018 RS7 vehicles equipped with basic seats (with or without heating). Stress or wear of the body-sensing mat within the front passenger seat may cause the Passenger Occupant Detection System (PODS) control module to malfunction.

  Remedy: Volkswagen will notify owners, and dealers will install a PODS system repair kit, free of charge. The recall began November 29, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74D5.

2016 Audi A6 safety ratings

Source: NHTSA NCAP ratings.

2016 Audi A6 owner complaints (15)

• UNKNOWN OR OTHER,FUEL/PROPULSION SYSTEM

  There is a recall out for “2016 Audi A6 vehicles” the recalls are “fuel system rail” as well as “coolant pump”. Both recalls are vin specific and what I find to be devastating is that both recall risk pertains to possible fire! I have the exact issues with my vehicle I even have the epc light coming on and the code is “fuel rail system” I also have an ongoing issue with my coolant system. I have documentation that I’ve paid out of pocket to take care of these issues, however being that there is no current open recalls under my vin number I do not believe mechanics know exactly what to do to fix the issues. The vehicle is misfiring, shutting off and the EPC code is stating “fuel system rail” along with the coolant leaking. I have a [XXX] daughter and to be such an expensive vehicle, I thought I would feel safe and valued. I’ve worked as a service BDC manager for years and at other dealerships when a situation like this would occur, we still wanted them to bring the vehicle into the dealership and if it was in fact relatable to the recall we would take care of it, regardless to it being “vin specific”. There is a such thing as “silent recall”. I really hope that you all can take this as an emergency case and help with such terrible situation. Thank you so much. I can be reached at [XXX] my name is [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• FUEL/PROPULSION SYSTEM

  I own a 2016 Audi A6 3.0T. After filling the fuel tank completely, the vehicle only traveled approximately 190–200 miles before the fuel gauge indicated empty. This represents a sudden and significant loss of fuel range compared to normal operation. There are no warning lights, check engine lights, fuel smells, visible leaks, rough idle, or abnormal noises. The vehicle operates normally otherwise. The issue appears to involve excessive fuel consumption or incorrect fuel management without any driver warning. This condition poses a potential safety risk because the vehicle may unexpectedly run out of fuel while driving, which could result in loss of power in traffic or on highways, increasing the risk of an accident. The issue has been observed repeatedly after refueling. At the time of this report, the vehicle has not yet been inspected by a dealer or independent repair facility, but diagnostic evaluation is planned. Based on owner research and symptoms, the issue may be related to a fuel system, engine management, or emissions-related component malfunction that does not trigger a warning indicator. No prior warning messages or lamps were displayed before or during the occurrence.

• ENGINE

  The water pump on my 2016 Audi A6 has failed multiple times prematurely. The first water pump failed at 36,965 miles in May 2019. That repair was covered under an extended warranty I purchased. The second water pump failed around 83,000 miles in September 2025, and Audi is now quoting me $2,350 out of pocket to replace it. I am now facing a third water pump replacement, which is far earlier than expected for this type of component. These repeated failures create a significant safety concern, as sudden coolant loss can cause the engine to overheat, potentially leading to engine failure or loss of power while driving. Each problem has been diagnosed and confirmed by an authorized Audi service center. The vehicle was inspected by Audi technicians, and repairs were recommended both times. The repeated failure of this critical component strongly suggests a systemic defect with the water pump design on this model. Despite a recent Audi water pump settlement, my vehicle was excluded, even though it has now experienced two failures and is requiring a third replacement.

• POWER TRAIN,AIR BAGS,ENGINE

  This vehicle had a claim for water pump replacement and the 3.0 model has a recall for the turbo charger. This vehicle is experiencing the same issues and went from 70 mph to 0 and stalled on the freeway. Thankfully the semi and other vehicles were able to avoid me or my family would be reaching out instead of me. Currently the vehicle is parked in my garage because it is unsafe to drive. Can you please advise Audi to take responsibility and offer the same recalls on the 2.0 vehicles for the water pump and turbo charger because they have the same internal parts as the 3.0 vehicles that failed and these parts were covered.

• ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM

  Engine area of car caught fire with ignition off

• ELECTRICAL SYSTEM

  The contact owns a 2016 Audi A6. The contact stated that while driving approximately 40 MPH, the vehicle suddenly experienced a loss of motive power and stalled. During the failure, the message Electric Power Control "EPC" was displayed. The vehicle was later towed to the local dealer who diagnosed that the electric wiring harness located in the engine compartment had failed due to moisture intrusion and the harness along with an internal computer needed to be replaced. No further information was available. The vehicle was not yet repaired. The failure mileage was 49,000.

• POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  I took the vehicle into a repair shop because the check engine light is on. I was advised that the water pump is leaking and it needs to be replaced along with the thermostat. The turbo charger assembly also needs to be replaced. Both of these items appear to be deficient and were listed under recent recalls on similar Audi vehicles and this VIN was not included in either recall. However, it appears to be a similar concern and should be resolved by the Manufacturer.

• FORWARD COLLISION AVOIDANCE

  I am the original owner of my vehicle and have had my vehicle maintenance done at Niello Audi in Sacramento, CA. In May 2023, the forward facing camera on my 2016 Audi A6 stopped working. The dashboard error message was "ACC and Audi braking guard Unavailable". As a result, the automatic emergency braking, forward collision warning, lane keeping assist, and cruise control stopped working. In June of 2023 I took the vehicle in to the above named dealer and they indicated that the front facing camera would need to be replaced but they could not do so because the part in on back order. The part number is 4H0907217FX. Ever since June 2023, the dealer has indicated that the part is still on back order and unavailable. Today March 28, 2024, I contacted AUDI USA and was informed that Audi stopped making that part and it is no longer available. I have been waiting almost a year for Audi to correct this to no avail. The part in question is tied to several safety systems (emergency braking, collision warnings, etc.) and I feel that my vehicle is unsafe to drive. Obviously, this concerning safety issue affects all Audi owners in the United States and I think Audi should immediately be required to fix this safety issue.

• FORWARD COLLISION AVOIDANCE

  The camera associated with the adaptive cruise control and collision warning systems thought there was an object in the road multiple times while on active cruise control. This resulted in the brakes being engaged - could have been rear ended very easily causing an accident. The camera system has now stopped working all together resulting in the safety systems being disabled entirely as well as the cruise control. After researching the issue and talking to the dealership I have found the camera to be a very common part failure with all Audi's. I can't even get the part there is such a large demand for repairs.

• STEERING

  While driving the car, the steering column failed, making the car unable to steer. Mileage 81,312. The error message was Steering Malfunction, do not drive. and you could not turn the wheel. The independent service center confirmed and replaced the steering column. They stated they are doing 1-2 a week and Audi knows it's an issue as they are stocking the column. The repair cost me $5,000.00. There was no warning until it didn't work.

• ENGINE

  During annual oil change inspection the mechanic found that the coolant was leaking and that the water pump needed to be replaced. The car has under 48000 miles.

• SERVICE BRAKES

  At high speeds (around 65 or more), when I apply the brakes I can sense some vibration in the brakes. I mentioned to the dealer that the brakes are not smooth as in my other cars. I was told, it is because Audi is a "performance car." Now I know that it is just poorly built.

• SUSPENSION

  The dealer inspection found that the fluid was leaking from engine motor mount. The car has 47,700 miles.

• ENGINE AND ENGINE COOLING

  The contact owns a 2016 Audi A6. The contact stated while having routine maintenance on the vehicle, the independent mechanic became aware that the water pump was leaking. The contact was informed that the water pump, the thermostat assembly, and the upper coolant pipe needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was 26,205.

• ENGINE

  I left a gas station located one mile from my house. All seemed well. I drove into my garage, shut the engine off, and saw steam coming from under the hood. Inspection showed coolant below minimum level. I had the car towed to a garage. The water pump seal and water pump had failed. The thermostat also failed. I had no warning that anything was about to happen. No warning lamps or alarms were presented. Had this happened on the freeway, the engine would have overheated and locked up before I knew that there was a problem. I would have lost control of the car. The mechanic said that this failure at such low mileage, 51, 803, was unusual. My experience is that a failed water pump should not be expected before at least 150,000 miles of use.