2017 Ford F-150

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.

Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

SEAT BELTS:PRETENSIONER

Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.

Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.

Remedy: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Ford Motor Company (Ford) is recalling certain 2017 F-150 and Mustang vehicles. The air bag inflator within the passenger frontal air bag module may rupture in the event of a crash.

Remedy: Ford will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began October 11, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S26.

SEAT BELTS:REAR/OTHER

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Remedy: Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17C12.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."

Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Ford Motor Company (Ford) is recalling certain 2017 F-150 trucks equipped with an eight-inch productivity screen. In these vehicles, the instrument cluster may lose power after the initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicles Safety Standard (FMVSS) number 102, "Transmission shift position sequence, starter interlock, and transmission braking effect."

Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began February 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C01.

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles equipped with ten-speed transmissions. The pin that attaches the transmission shift linkage to the transmission may come out, preventing the transmission from responding to movement of the shift lever.

Remedy: Ford will notify owners, and dealers will replace the roll pin with an updated part, free of charge. The recall is expected to begin December 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S36.

POWER TRAIN:AUTOMATIC TRANSMISSION

Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.

Remedy: Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S09.

SEATS

Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."

Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.

SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

Tenneco Automotive (DRiV) is recalling certain MOOG K500359 ball joints, for aftermarket installation on 2015-2018 Ford F-150 trucks. The ball joint may have a misaligned dust boot and may be missing alignment hole and installation warning tag, which may lead to improper alignment of the ball joint.

Remedy: DRiV will notify owners, and dealers will inspect, and if necessary replace the ball joint, free of charge. Owner letters were mailed May 5, 2021. Owners may contact Tenneco Automotive customer service at 1-877-489-6659.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.

Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.

Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.

POWER TRAIN:AUTOMATIC TRANSMISSION

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150 vehicles. A loss of signal between the transmission range sensor and the powertrain control module can cause the transmission to unexpectedly downshift into second gear.

Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 24, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S28. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Ford Motor Company (Ford) is recalling certain 2017 F-150 vehicles previously repaired incorrectly under recall number 17V053. The instrument cluster may lose power after initial vehicle start-up in cold ambient temperatures. Several gauges, including the transmission gear position indicator, may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect."

Remedy: Dealers will update the Instrument Panel Cluster Assembly (IPC) software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C26. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.

The 4-5-6 drum ring in my transmission went out on my truck that has 70, 318 miles on it. Vehicle was missing shift points and would not always shift properly causing power to not be available when expected - especially dangerous when trying to merge onto a highway. Vehicle was inspected by a Ford dealership and by ABC transmissions of Tacoma WA. I paid ABC Transmissions $9,693.98 to fix the problem. The transmissions would clunk badly and was very obviously missing shift points. They first appeared 30k miles ago but Ford lied to me saying it was a "software problem".

I am filing this complaint because a Ford-authorized dealership, West Hills Ford in Bremerton, Washington, returned my vehicle to me in an unsafe condition after performing a repair under federal safety recall 25S37 (NHTSA Campaign 25V-236, brake master cylinder), and because an independent inspection has since documented physical evidence of a real defect connected to that repair. Please see attached documents outlining this entire incident as well as supporting documentation.

Vehicle is subject to active Safety Recall 26S28 for transmission lead frame and range sensor failure causing unexpected downshifts into 1st gear. Vehicle experienced downshifting symptoms creating severe road hazard and risk of rear-wheel lockup. Dealership cleared diagnostic trouble codes without saving freeze-frame logs, mis-entered VIN on billing estimates, and refused to complete the recall repair. Vehicle is available for inspection.

Odometer Fraud. The contact purchased a 2017 Ford F-150. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of the purchase, the vehicle mileage was approximately 170,000, and it was later discovered via a third party that the mileage was 250,000.

On XXX, my [XXX] son was driving this 2017 Ford F-150 when the transmission suddenly downshifted while traveling on the road. The downshift was severe enough that the rear tires lost traction and the vehicle fishtailed, nearly resulting in an accident. The vehicle was taken to an authorized Ford dealer on 8/18/2026. We reported the sudden downshift, but the dealer was unable to duplicate the condition. The dealer performed Ford Recall 26S28/NHTSA 26V-237 and campaign 19G01, and the vehicle was returned on XXX. On XXX, only two days after the recall repair, the engine unexpectedly shut off while the vehicle was being driven. It restarted afterward. On XXX, the engine again unexpectedly stalled while the vehicle was moving. When the engine stopped, power-steering assist was lost and the driver had to coast the vehicle safely to the side of the road. The engine restarted immediately. When attempting to drive away, the transmission appeared to be starting in approximately third gear rather than first gear. After the vehicle was moving, the transmission eventually began operating normally again. Ford Customer Relationship Center was notified on XXX and formally documented these incidents. The vehicle is available for inspection. I am concerned because the original sudden downshift closely resembles the safety defect addressed by Recall 26V-237/26S28, and serious intermittent stalling and abnormal transmission operation have continued after the recall remedy was performed. I am requesting that NHTSA document and evaluate these post-recall safety symptoms and whether the recall remedy adequately addresses the underlying defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driving back from tri cities and when we were on I5 the transmission abruptly shifted down and went to a very high RPM. Was able to limp off the freeway by UW, and then drove home slowly. Had it trailered by the dealership i had just bought it from and they brought it to a shop where they said the transmission needed replaced.

In late July 2026, my son received a Ford safety recall notice (Recall #26S28) for his 2017 F 150 requiring a PCM software update. I brought the truck to Crown Motors in Redding on August 11th for the recall service. Before this appointment, the truck had no performance issues. Immediately after picking up the truck, a noticeable pinging sound occurred under acceleration. I returned the vehicle on August 12th, where Crown Motors confirmed the issue and advised spark plug replacement. This did not resolve the problem. I was also told that continued driving could damage the engine, so the truck remained at the dealership. Over the following days, Crown Motors worked with Ford engineering and repeatedly attempted software-related fixes. Crown staff informed me they believed the recall update caused the issue, and the first internal Ford team reportedly agreed. However, on August 25th, Ford’s second internal review determined the software update was not responsible and stated that all repair costs would fall on me—despite the clear timeline showing the problem began immediately after the recall service. Customer Service provided no assistance and refused to escalate my concern. As a result, my truck is currently non-operational, Crown Motors does not have a fix, and Ford will not cover repairs triggered only after Ford’s own safety recall. According to NHTSA’s info, it seems Ford is obligated under Motor Vehicle Safety Act (49 U.S.C. § 30111 et seq.) to repair the vehicle. I am requesting that Ford acknowledge responsibility for the recall related issue and cover the necessary repairs. I am deeply concerned at the lack of support and accountability shown throughout this process from Ford. I am resubmitting this info, not sure if my first attempt worked. I had an issue with my internet browser.

This lead frame issue is never ending. Well over a decade without a proper remedy. I’m very familiar with it. but this one nearly ended my life. After the near collision I called my mechanic and bought a new ford lead frame from a dealership. It’s doing fine now, it’s been 1 year. the incident caused my truck to go into park or possibly reverse at highway speed just as I passed a semi truck and returned to the right lane. If the trucker had not been paying attention it would have been bad. There was nothing I could do. . On top of this, he was under the impression that it was intentional. So I almost got into a physical altercation until I convinced him to look inside my truck as my gear indicator light was dancing from gear to gear while not touching anything.. To add to the seriousness, my taillamps never came on because I didn’t touch the brake. It was a horrible timing.. . Shortly after this i received a notice from Ford explaining the cause and symptoms of this issue, but then stated there was no fix at the time, but the vehicle was “safe to drive.” That is irresponsible. This was the only time mine did it, no prior issues. I got new ford parts and had it replaced. my mechanic said they deal with this weekly! Then I get a letter from Ford saying there is a fix and it’s a computer programming issue which is totally not true. That’s just a smoke screen, but it also goes on to say it could be a lead frame and if you’ve already fixed it before you got a letter, they will refund your money, but I highly doubt that. But they should stop claiming these vehicles are safe to drive because they absolutely are not if they’re having an issue regarding recall 26S28. So not only did i use new Ford parts, I paid a reputable EX Ford Technician Who owns his own business to perform the services because ford didn’t offer a fix. only to waste my time reprogramming the ecm. I work, I don’t have time.It’s irresponsible to say it’s not a safety concern. It’s just bad policy

Short in the rear window defroster. Within 5 minutes of turning off the defroster after only having it on for 2 minutes at 2:30am leaving work, the back window exploded outward and shattering. No rocks, no other folks on the road. Upon research, and after contacting insurance company and the glass repair company, this is a very common issue in 2015-2019 F-150s. But there are no safety recalls. Praise God my children were not in the backseat, they would have been riddled with glass. How is this not a safety issue?

Not sure if I can file an issue for this, but I wanted to let you know that a Ford Safety recall caused other issues after it was applied. In late July 2026, my son received a Ford safety recall notice (Recall #26S28) for his 2017 F 150 requiring a PCM software update. I brought the truck to Crown Motors in Redding on August 11th for the recall service. Before this appointment, the truck had no performance issues. Immediately after picking up the truck, a noticeable pinging sound occurred under acceleration. I returned the vehicle on August 12th, where Crown Motors confirmed the issue and advised spark plug replacement. This did not resolve the problem. I was also told that continued driving could damage the engine, so the truck remained at the dealership. Over the following days, Crown Motors worked with Ford engineering and repeatedly attempted software-related fixes. Crown staff informed me they believed the recall update caused the issue, and the first internal Ford team reportedly agreed. However, on August 25th, Ford’s second internal review determined the software update was not responsible and stated that all repair costs would fall on me—despite the clear timeline showing the problem began immediately after the recall service. Customer Service provided no assistance and refused to escalate my concern. As a result, my truck is currently non-operational, Crown Motors does not have a fix, and Ford will not cover repairs triggered only after Ford’s own safety recall. I believe the Spark Knock issue is an additional safety issue caused by the PCM recall update that was I was told could cause engine failure.

I am filing a formal complaint regarding improper service practices, breach of safety recall protocols, and severe resulting vehicle damage committed by Fox Grand Traverse Ford. On April 23, 2026, independent facility Kinney’s Complete Auto Repair replaced the lead frame connector on my vehicle. During service, the transmission pan was dropped and inspected. The transmission was certified clean, free of metal shavings, and operating normally. On August 3, 2026, a mobile service technician from Fox Grand Traverse Ford performed Safety Recall 26S28 (PCM Software Update) at my workplace parking lot. Ford Motor Company’s official support guidelines explicitly state: "Ford Mobile Service is unavailable for Recall 26S28." Servicing requires in-dealership PCM reprogramming and post-flash adaptive calibration. Because the service was performed in a parking lot, the technician omitted the mandatory post-flash adaptive learning drive cycle. The vehicle immediately suffered harsh shifting, hydraulic pressure spikes, and forward rolling while in Reverse. Fox Ford now demands $7,883.73 for a complete transmission replacement, falsely claiming there metal shavings in the gear box and that the damage was a "pre-existing condition," despite the recent clean pan inspection from April 2026.

The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted to first gear, causing the rear wheels to lock up. The contact pulled over, turned off and restarted the vehicle. The vehicle was taken to an independent mechanic, and the transmission was rebuilt, but the failure persisted. The contact later received notification of NHTSA Campaign Number: 26V237000 (Power Train). The vehicle was taken to the dealer for the recall repair; however, the failure reoccurred. The dealer was made aware of the failure and informed the contact that a diagnostic test was needed. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 71,200.

My 2017 Ford F-150 equipped with the 10R80 10-speed automatic transmission experiences repeated harsh and unpredictable shifting. The transmission will hesitate or delay during shifts and then engage very hard, sometimes producing a severe bang or jolt through the truck. It also experiences abnormal gear hunting and inconsistent shifting behavior. These symptoms can occur during normal driving and create a safety concern because the transmission does not always respond predictably to driver input. Ford has issued technical service bulletins addressing harsh engagement, delayed engagement, harsh shifting, and delayed shifting on 2017-2020 F-150 vehicles equipped with the 10R80 transmission. My vehicle is experiencing these same types of symptoms. I am reporting this because I believe the 10R80 transmission in affected 2017 F-150 vehicles should be investigated for a potential safety defect.

I have been trying to get this recall resolved. This truck was at the Metro Ford dealership in Tupelo, Mississippi for over one week in July 2026. Replacement parts sent to dealership were also recalled. Dealership ended up placing original part back on the truck. How can this issue be resolved?

PCM not communicating with throttle body causes wrench light to come on and we loose control of the gas and slows the car abruptly.