2019 Ford F-150

EXTERIOR LIGHTING:HEADLIGHTS

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.

Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.

Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

EQUIPMENT:OTHER:LABELS

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

EXTERIOR LIGHTING:HEADLIGHTS

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.

The transmission started to clunk into gear very heavily when I started my drive and then as I was driving down the highway going 60mph, the 10r80 transmission suddenly downshifted from 7th gear to 1st gear, and jolted the truck and I lost all power and it took around 5-7 seconds before the throttle was registering again to pick up speed. A car was a ways behind me but if it had been closer, there is no doubt I would have likely been hit. After this happened, in trying to increase speed back to the speed limit, the transmission would not shift back into 7th gear, and a wrench and code popped up on the dash.

Beginning approximately one year ago, my Ford F-150 has intermittently experienced a serious transmission problem during acceleration. The transmission appears to momentarily lose the connection between the engine and drivetrain. When this occurs, the truck hesitates or fails to deliver power when I press the accelerator, then suddenly and very harshly engages the next gear. The problem can occur when the vehicle is cold or fully warmed up. This creates a significant safety concern because the vehicle can unexpectedly fail to accelerate when needed, particularly when merging onto a highway, climbing a hill, or accelerating from a traffic light with other vehicles behind me. The sudden, harsh engagement that follows the hesitation is also unexpected and could affect the vehicle's stability or the driver's ability to control the vehicle. I contacted my Ford dealer on August 17, 2026, regarding the problem. The dealer indicated that they are familiar with this type of problem on this transmission and stated that their repair procedure is to replace the entire transmission rather than attempt to repair it. I was told the estimated cost would be approximately $10,000–$12,000. The truck currently has approximately 71,000 miles. Although it is no longer under warranty, I am concerned that a major transmission component is experiencing a potentially serious safety-related failure at this mileage. I believe Ford should investigate this issue and determine whether there is a defect or widespread failure affecting these transmissions. Given the nature of the problem and the potential safety consequences, I also believe Ford should provide financial assistance toward the repair, particularly if this is a known or recurring transmission problem.

CDF drum failure and torque converter failure. Started at 70,000 miles by shifting hard going into 8th gear. Now it has completely failed at 81,000 miles. It is a safety concern because now the vehicle goes straight to 4th gear when you shift out the park. Fourth gear is too steep to leave from a stop and can lead to somebody getting rear-ended. This is a well-documented problem for the 10r80 transmission and something needs to be done about it.

The contact owns a 2019 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was an abnormal sound coming from the vehicle. The vehicle was pulled over to the shoulder of the roadway. The accelerator pedal was depressed, and the RPM became elevated. The check engine warning light was illuminated, and the vehicle failed to go forward or backwards. The contact stated that the transmission failed to shift into the intended gear. The vehicle was driven to the residence. The contact stated that the failure was persistent. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was taken to the dealer several times since being purchased in 2019; however, the failure was not duplicated. The contact stated that the failure was persistent. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 15,407.

The transmission consistently slips, stalls, and shifts very aggressively between gears, specifically between gears 3-4, 7-8, and 6-5. This occurs at various speeds and levels of acceleration. This puts everyone on the road at risk as it makes it difficult to control the speed of the vehicle. Vehicle is available for inspection upon request. This was inspected at a Ford dealership and confirmed to be a problem by the transmission specialist. There are no warming lamps or error messages.

The transmission slipped out of gear while entering an intersection. Several slipping issues with transmission and Ford dealers refused to look into issue. They have recalled the 10 speed automatic transmissions for several years but not the mine?

What happened is i bought a truck that Ford knows good & well has a defective CDF drum and outer shell but they refuse to issue a recall to fix the transmissions in those year models! Yet in late 2022 they acknowledged the problem and updated the 22+ year models with the correct parts while leaving those of us with the prior 4yrs of trucks out in the cold! My truck is currently undergoing getting a new transmission and it hasn't even reached 70K yet. At 61K I had to have all timing components along with a new oil pump replaced due to the common oil consumption issues on the 13th gen models. Now 8K miles later I'm having to have a new transmission because it started with all the common problems and known issues that everyone else has had with the 13th gen trucks. This is absolutely ridiculous and no if's, and's or but's about it Ford should be liable for it! Every single one of us especially those of us below 100K should be reimbursed. It is a disgrace to own and pay for a vehicle that spends more time at the shop than it does in your driveway! I am fuming mad. Due to my age and health condition this was supposed to be the last vehicle I ever buy yet being on a fixed income I now have a truck that I cannot trust to get me safely to my Dr's appointments or even the local places I have to visit on a weekly basis. Absolutely ludicrous! I have all invoices of all work that has been done and that info has also been put into the Carfax records. The shop i use is very proficient when it comes to recording the information. Within a week once the new transmission is installed I will have that invoice as well as it being loaded into the Carfax records.

I bought my 2019 F-150 a few months ago used. Since then it’s been nothing but problems and honestly, terrifying one’s. The truck has shifted and driven rough since I bought it. But on some occasions it goes from rough driving to potentially accident causing. The truck will randomly decide it does not want to shift from a gear, meaning I can’t speed up on busy 95 traffic or move out of the way of aggressive drivers when needed. The truck also will occasionally shift up or down on its own without warning causing me to slow down quickly while already at interstate speeds. At this point, because I have no choice but to drive it to work, it’s a matter of waiting for the day it downshifts too far while in the interstate causing a crash. The fact that I am scared at times to drive my own vehicle and the manufacturer not being willing to fix it is alarming. Alarming because if this is something they can get away with now, what will they get away with in the future.

I am filing a safety complaint regarding the transmission in my 2019 Ford F-150 equipped with the 5.0L V8 and 10-speed automatic transmission. My vehicle currently has approximately 88,000 miles. The transmission began experiencing abnormal shifting, including skipping/hesitating between gears, harsh shifting, shuddering, and delayed engagement. At times it would appear to skip 2nd gear and go directly into 3rd. I brought the vehicle to a Ford dealership for diagnosis. Ford of Spartanburg performed testing and a road test. Their written diagnosis states that the PCM was tested and had no related DTCs. The technician documented delayed 1-2-3, 2-4 and 3-4 shifts, a 400-500 RPM flare during the 2-4 and 3-4 shifts, and a shudder during the 1-2 shift. The technician checked the transmission fluid and documented that the level was good but that the fluid appeared “super burnt.” The technician further stated “suspect CDF drum bushing shifted” and recommended replacement of the entire transmission assembly. The Ford dealership's estimate for the recommended transmission replacement is $8,737.05. I am concerned that a major internal transmission failure involving the CDF drum/bushing can occur at approximately 88,000 miles and result in delayed, erratic, harsh or unexpected shifting. I am particularly concerned about the potential safety implications if the vehicle unexpectedly loses acceleration or does not respond normally while entering traffic, passing, or traveling at highway speeds. I am requesting that NHTSA document this complaint and investigate whether this represents a broader safety-related defect affecting Ford vehicles equipped with this transmission. I have retained the Ford dealership's diagnostic documentation and can provide it if needed.

My transmission slips from 3rd to 4th gear and sometimes when on the highway from 7th to 8th or it will get stuck in 7th gear when going 75mph. The check engine light went on once and has been off ever since.

vehicle shifted from 1st to 3rd gear and as I accelerated the engine RPMs drastically increased. The transmission jumped from 3rd to 8th gear and then immediately dropped to 1st gear while I was at 40-45 mph. Due to the speed the back tires locked and the vehicle jumped from 1st to 3rd gear and I stopped. Thankfully I did not have a vehicle behind me, or they would have him me. Dealership determine and confirmed hard/harsh shifting between 3rd, 5th, 6th while skipping 4th and 5th. No codes or warnings found upon download by the technician. Technician could not replicate it shifting from high gears to 1st and locking the tires. Recommended and completed adaptive learn procedure, but vehicle is still hard shifting 3rd and 4th gear. Very concerned the vehicle could downshift from higher gears and lock the tires again which will cause an accident.

I started noticing hard and delayed shifts from 7th into 8th gear. My RPM's were not increasing when this happened, and then on a very crowded major road I lost all power, vehicle shut off and drifted, then started up and jerked again very hard. This failure could have caused a severe accident and jeopardized the well being of my wife, daughter, her friend and myself along with any other people that could of potentially been involved in a collision if one had occurred. My dash showed no warning lights. After lots of research and consultation with a private owned mechanic shop, I learned the 2019 F150 has a sever and known transmission issue with the learning tables and the transmission control module resulting in failure. Further research reveled a law suit against ford ([XXX] v. Ford Motor Company (Case No. [XXX] in the U.S. District Court for the Northern District of Illinois, targets Ford over alleged defects in the 10R80 10-speed automatic transmissions equipped in 2017–2020 Ford F-150 trucks) regarding this exact issue I was having with my truck, with only 72,000 miles on it! Bob Bell Ford in Glen Burnie Maryland, was less than helpful and the staff was rude when I was explaining what was happening and the information I learned, and quoted me a price of around $12,000.00 to replace the transmission, and that they knew there was a problem with that transmission. I had the vehicle repaired by Glen Burnie Transmission in Glen Burnie Maryland for $8,200.00. That shop told me that they replace several of these transmissions a month (confirming it is a sever issue) and the service tech could tell me what the 8th digit in my vin was based on the symptoms, and he was spot on! I was told the CDF drum and bushings failing—that cause harsh, erratic shifting, sudden lunging, jerking, hesitation, and gear slipping This repair costed me $8200.00 to replace, and another $450 to Bob Bell Ford for them to repeat to me what I already told them. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My truck has routinely been very hard shifting in 3rd to 4th gear. Recently it downshifted from 8th to 4th without warning and made a loud clunking noise. It still runs, but the transmission seems to be getting worse.

When driving, especially from a low gear (2-5), the transmission will downshift to 1, high revving, and then slam back into 4 or 5th, depending on where it downshifted. Sometimes the rapid acceleration causes the back of the truck to start to break lose. I notice this alot when trying to get up to speed, and can usually take my foot off pedal and it will slow the vehicle and upshift.

Shifted into 1st gear from 10th while driving 70mph