2020 Ford F-150

TIRES:BEAD

Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.

Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.

EXTERIOR LIGHTING:HEADLIGHTS

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.

Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

ELECTRICAL SYSTEM:STARTER ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.

Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.

Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES

Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.

Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.

EQUIPMENT:OTHER:LABELS

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

EXTERIOR LIGHTING:HEADLIGHTS

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.

Transmission shifted from 4th to 1st while driving a steady 25 mph, then lost all forward drive, the transmission slips, then will slam into gear. I parked it for two weeks until I could get it to the shop. Driving it to the Ford dealer today (2 September 2026) I had to stop the vehicle twice because the transmission was doing the same thing. Currently have 70K miles on it.

Harsh shifting from 3rd to 4th and 7th to 8th

After starting my 2020 Ford F150 for the last few months on the dash 2 warnings comes up, Front Camera Malfunction Service Required and Pre Collision Assist Not Available. These come on every time I start my truck. I did go to my local Ford dealer and told them these were coming on and they told me they never heard of that. I did have a mechanic do a scan on the truck and he came up with code 4300-49- AF which he said is an internal electronic failure. I have read that people have been having this same issue with their 2020 Ford F150s. I feel this is a safety issue that Ford should address. When system is not working it could lead to accidents which is why this would of been installed on vehicles. I have not had the issue fixed due to the fact the dealer told me they had never heard of this issue and would have to put it on a machine to see if they could even figure out the problem which could run into hundreds of dollars plus repairs and I am on a fixed income. Vehicle is available about any time to check this out.

I am reporting a safety-related transmission problem I experienced with my 2020 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission shifts hard (ie: jerks, clunks) between 4-5 and 5-6 gears, and has on occasion failed to grab 1st gear when starting from a stop (revs, doesn't go). This occurred while turning across traffic, creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data to determine whether this is a safety defect requiring a recall. I believe owners should not have to wait for a potentially dangerous transmission failure before this known condition is addressed. Furthermore, I have already had two transmission rebuilds under warranty, and it's going back to the shop for a third time with the same issues 9/8/26. THE SAME ISSUES. I bought this truck in 2024 at 70K miles and it has been nothing but problems.

When driving the vehicle it randomly jumps gears, when taking off it went into limp mode today. My wife almost got slammed by a semi truck! I called ford and they are not interested in hearing my case only wanting me to pay these outrageous fees. The pcm recall fix did not fix the gears jumping

While driving I will get a wrench symbol with a bunch of codes pop up u0121:00:28 u0131:00:28 u0137:00:28 u0164:00:28 u0199:00:28 u0200:00:28 u0212:00:28 u0252:00:28 u0256:00:28 u1012:00:28 p0557:00:28 p1935:00:68 p193e:00:28 I have also had it jerk while driving ( went down into first gear) while having no power to my gauge cluster ac nothing

Severe transmission shifting delays, unresponsive when accelerating. Shutters and skips when coming to a stop.

Transmission shifts from a higher gear to 1st when going over 60, also transmission has a hard time shifting skips 2nd, 4th, and sometimes 6th gear.

Went to speed up as I was approaching a ramp going uphill and almost towards the top the truck decided to down shift to first gear going about 45 mph. No accident occurred as no one was around me.

Harsh shifting in between gears. Jerky shifting and shudders while shifting as well

MY PICKUP HAS THE 10R80 TRANSMISSION. IT CURRENTLY SLIPS IN LOWER GEARS AND SOMETIMES NO 10TH GEAR

Vehicle had hard and sudden shifting and grinding noise coming form gears. Sudden shifting would result in abrupt change in speed. Two repairs were made by a Ford dealership totaling just over $10,000 including replacing transfer case and transmission. There was no vehicle warning indicators that notified me of this problem.

Truck equipped with the 10R80 downshifted from 10th gear to 1st gear while on the freeway doing 80mph. NOT SAFE AT ALL.

There has been harsh shifting observed, both cold and warm. Often when downshifting and slowing to a turn or stop, there is a violent slamming into gear. I have also observed slipping in 3rd gear and making harsh shifts that appear to skip gears by the indicator. This is not a constant but intermittent issue. I have not taken it to the dealership because they will likely not be able to duplicate it in a reasonable amount of time.

Transmission started "clunking" and shifting erratically over a two week period before warning light came on that said "powertrain needs attention...contact dealer" Took the car to Monticello Ford in Monticello NY and they tested it based on diagnostic code and replaced filter and fluid. They reset the computer and told me to drive it for a week so computer could "relearn" driving habits. Drove truck for 4 days and once again transmission started clunking and shifting hard with loud thunks when transmission gears engaged. Had my [XXX] grandaughter in the truck with me on the highway when the transmission started to slip and would not engage. Other vehicles had to brake suddenly to avoid hitting me. Had to pull over and restart truck to get the transmission to re engage. Transmission issues have been a known problem with the Ford F 150 trucks since 2017 and yet Ford has done nothing to correct the problems with their customers.....there are currently three outstanding class action lawsuits against them regarding the faulty transmissions.....this is a SAFETY issue that Ford must be held accountable for and fix these trucks at NO COST to the customers who own these trucks immediately!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)