2023 Honda CR-V

2023 Honda CR-V recalls (3)

• SEATS:FRONT ASSEMBLY:RECLINER

  Honda (American Honda Motor Co.) is recalling certain 2023 CR-V vehicles. The front passenger seat back frame may not have been welded properly, which can cause the seat back position to fail in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 201, "Occupant Protection in Interior Impact."

  Remedy: Dealers will replace the front passenger seat back frame assembly, free of charge. Owner notification letters were mailed March 27, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6PK.

• FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.

  Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.

• STEERING

  Honda (American Honda Motor Co.) is recalling certain 2023-2025 Acura Integra, Civic Type R, CR-V Hybrid, CR-V, HR-V, 2022-2025 Civic, Civic Hatchback, 2024-2025 Acura Integra Type S, 2025 CR-V Fuel Cell EV, Civic Hybrid, and Civic Hatchback Hybrid vehicles. The steering gearbox assembly may have been manufactured incorrectly, which can cause excessive internal friction and lead to difficulty steering the vehicle.

  Remedy: Dealers will replace the worm gear spring and redistribute or add grease as necessary, free of charge. Owner notification letters were mailed November 18, 2024. Owners may contact Honda Customer Service at 1-888-234-2138. Honda's numbers for this recall are SJS, MJU, QJT and VJV.

2023 Honda CR-V safety ratings

Source: NHTSA NCAP ratings.

2023 Honda CR-V owner complaints (15)

• WHEELS

  Vehicle was brought in for steering gearbox recall repair. After the recall was performed, the vehicle developed a loud thumping noise from the front passenger side. Upon returning to the dealer for diagnosis, the dealer found the passenger front wheel was missing 3 lug nuts and had only 1 lug nut holding the wheel on. The lug lock was also loose. The vehicle was driven at highway speeds in this condition. The dealer's own work order confirms these findings. The missing lug nuts were a direct result of the recall repair service.

• ENGINE AND ENGINE COOLING

  The contact owns a 2023 Honda CR-V. The contact stated that while driving at various speeds, the message "Engine Overheating Do Not Drive" displayed, and a red Check Engine warning light illuminated. The contact smelled smoke and observed smoke coming from the interior vents. On each occasion, the contact pulled over safely, turned off the vehicle for nearly an hour, and then restarted the vehicle. The vehicle was taken to a dealer, where it was diagnosed that the head gasket had failed with potential engine damage, and the head gasket and engine needed to be replaced. The vehicle was not repaired. The contact associated the failure with an unknown recall. The manufacturer was notified of the failure. The failure mileage was 193,000.

• STEERING

  The contact owns a 2023 Honda CR-V. The contact stated that while operating the vehicle, several warning lights remained illuminated, including the Tire Pressure Monitoring System (TPMS), power steering, and check engine warning lights. Additionally, the steering wheel became difficult to turn in either direction. The vehicle was taken to a local dealer, where it was diagnosed that the steering rack needed replacement. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 48,000.

• ELECTRICAL SYSTEM

  Battery overheats and emits visible smoke from positive terminal and strong sulfur (rotten egg) odor. Notices the problem a few days ago. Called AAA for assistance on Sunday August 23 and technician stated that a lot of Hondas have had this issue including his own and it is due to a recall. A search online shows a recall issued for approximately 98 2023 Honda crv hybrids for Electrical system: Propulsion system: Traction battery date 2024-10-02 Recall no. 24V745000 Honda (American Honda Motor Co.) is recalling certain 2023 Honda CR-V Hybrid vehicles. The high voltage battery modules may have been manufactured incorrectly, which can cause the battery terminal or busbar to break and spark.

• UNKNOWN OR OTHER

  I own a 2023 Honda CR-V EX-L 1.5L turbo. My vehicle has repeatedly displayed an “Active Grille Shutter System Problem” warning while driving. Diagnostic trouble code P16E8 has also been associated with the active grille shutter system. The problem has occurred multiple times, particularly during hot weather and while driving on steep grades. When the active grille shutter warning occurs, the vehicle can go into reduced-power mode, significantly limiting its performance. Turning the vehicle off and restarting it may temporarily clear the warning and restore normal operation, but the problem can return. The vehicle has not been overheating when this occurs. I am concerned because unexpectedly entering reduced-power mode while driving, especially on a highway or steep grade, could create a safety hazard. I am reporting this issue so NHTSA can document and investigate whether there is a recurring defect involving the active grille shutter system on 2023 Honda CR-V vehicles and determine whether a safety recall or other action is warranted.

• TIRES

  The contact owns a 2023 Honda CR-V equipped with Michelin Tires, Tire Line: Michelin, Tire Size: 235/55/19, DOT Number: (N/A). The contact stated that the vehicle was serviced and the tires were rotated; the technician became aware that the tires were not properly aligned. The local dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed and determined that all four tires needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 30,000.

• STEERING

  I purchased this vehicle in November 2025. There was an existing recall remedy under NHTSA 24V-744. In December 2025 I took my vehicle to Brickell Honda to have the official steering gearbox safety recall performed. However, the dangerous "sticky" and binding steering sensation remained. On July 30, 2026, the dealership diagnosed the car and confirmed that the entire power steering rack is bad and must be replaced at a cost of over $4,400.00. The dealership offered a 50% goodwill split, leaving me with a $2,251.00 out-of-pocket expense. I formally declined the 50% offer, and I requested that Honda Corporate cover 100% of the parts and labor to replace the steering rack. The initial recall remedy failed to resolve the safety hazard in my vehicle.

• STEERING,FUEL/PROPULSION SYSTEM

  The rock and pinion is not working. The is an issue with the fuel emission. Engine light is on for both.

• ENGINE

  On my 2023 Honda CR-V with 79,567 miles, the engine experienced a cylinder 1 misfire while driving, causing the vehicle to lose power and enter limp mode. At the same time, every warning light on the dashboard illuminated. The sudden loss of power created a serious safety risk because I was unable to accelerate normally and had to safely maneuver the vehicle out of traffic, increasing the risk of a collision. I took the vehicle to an authorized Honda dealership, where the problem was confirmed and the engine was diagnosed with a blown head gasket. The vehicle has been inspected by the Honda dealership but has not been inspected by police, insurance representatives, or any other parties. Prior to this incident, there were no warning lights or messages indicating a problem.

• UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  The honda dealer states that the clip/ brackt that holds the multi view camera has broken. There is no damaged to the windshield or housing of the camera, the clip just failed and they could not tell me why. The vehicle has never been in any accident and has never had any damage. Adaptive cruise, cruise control, auto high beam, lane keep assist, Road departure, object detection, collision mitigation, traffic jam assistance, Sign recognition, and low speed braking control are not functioning as a result. Car is displaying multiple error messages. The honda dealer inspected and confirmed all the effective systems because the camera not being properly secure to the windshield by the broken clip.

• STEERING

  This complaint is a formal report of a FAILED RECALL REMEDY regarding NHTSA Campaign 24V-744 (Honda TSB 24-052) on a 2023 Honda CR-V (VIN: [XXX]). The official recall remedy (worm gear spring replacement and grease application) was previously performed and marked as completed on this VIN. However, the vehicle is actively exhibiting a complete reoccurrence of the exact severe safety defect described in the recall. At highway speeds, the steering wheel exhibits sudden "sticky," binding resistance, requiring increased physical effort to turn, which leads to immediate overcorrection and a severe crash hazard. The vehicle was taken to an authorized Honda dealership for diagnosis of the recurring symptom. The dealership service department confirmed there was an issue and recommended a total steering rack replacement. American Honda Corporate has refused to cover the replacement, claiming a "steering rack" is separate from the recall scope. However, the defective worm gear targeted by Campaign 24V-744 is located entirely within the steering gearbox, which is structurally integrated into the steering rack assembly. The manufacturer's remedy has failed to permanently cure the safety defect on this vehicle, leaving it unpredictable and dangerous to operate. The manufacturer is currently refusing to provide a secondary remedy to make the vehicle roadworthy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• STEERING

  I was driving in Houston and I tried to turn left to avoid someone hitting me from the back do to a slow down and I couldn’t turn left my gear was too stiff to turn. I got hit from behind and it turn into a hit and run. That affected me a lot due to the hurt and lack of work due to it all became behind and I am still suffering from that accident. I informed Honda and requested a buy back and help with the damages and losses but they denied the help and have affected my credit because since that accident it has been very hard for me to manage because of the recovery process.

• ENGINE

  2023 CR-V Sport Hybrid suffered a catastrophic cylinder 3 coolant leak/head gasket failure at 76,884 miles. Due to a lack of available Honda gasket kits and extreme dealership repair quotes, a full engine replacement was required.

• STEERING

  Vehicle: 2023 Honda CR-V Hybrid Component: Steering (Electronic Power Steering / EPS Gearbox) Description of Safety Defect: While driving at highway speeds (above 45 mph), the steering wheel experiences a severe "sticky," "notchy," or binding sensation. It catches when making minor directional adjustments, requiring excessive and abrupt physical force to break the wheel free. This causes a dangerous over-correction hazard, creating an immediate risk of a crash or loss of vehicle control. This vehicle is exhibiting the exact mechanical failure symptoms described in NHTSA Safety Recall 24V-744 (Honda Service Bulletin 24-052) regarding a swollen worm gear and overtightened spring preload. However, when entering my 17-digit VIN into the NHTSA lookup tool, the vehicle shows up as excluded from the current recall population. The local authorized Honda dealership has diagnosed the vehicle, confirmed a complete failure of the electronic power steering rack assembly, and quoted a $5,000 out-of-pocket replacement. I am filing this complaint to formally report that the manufacturing defect identified in Recall 24V-744 is actively impacting vehicles outside of Honda's currently defined VIN production window. I request that the NHTSA investigate and expand the recall population to include all 2023 Honda CR-V Hybrid vehicles suffering from this systemic, catastrophic steering column failure.

• ELECTRICAL SYSTEM,LANE DEPARTURE,FORWARD COLLISION AVOIDANCE

  While driving my car it will randomly go into limp mode, the dashboard lights up, and rotates through a list of issues wrong including brake systems, AWD, cameras, lane assist, etc. the dealership had me pay $450 for a system update, 10 hours after picking it up the problem occurred again and my car broke down in an intersection on a country road. I had it towed to the dealership and paid $270 for a new battery because they said it failed. I picked the car up the night of 7/2/26 and today (7/6) it broke down as I was leaving work with the same error. The dealership said there is no bulletin for the issues I am experiencing and they will get a Honda Tech involved.