2025 Hyundai Santa Fe

2025 Hyundai Santa Fe recalls (5)

• ENGINE AND ENGINE COOLING:CRITICAL FASTENERS

  Hyundai Motor America (Hyundai) is recalling certain 2025-2026 Tucson and Santa Fe vehicles. The connecting rod bolts in the engine may have been improperly tightened, which can cause a loss of drive power and engine damage, possibly resulting in an oil leak.

  Remedy: Dealers will replace the engine, free of charge. Owner notification letters were mailed October 23, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 281.

• ELECTRICAL SYSTEM:STARTER ASSEMBLY

  Hyundai Motor America (Hyundai) is recalling certain 2024-2025 Santa Fe vehicles. The B+ positive terminal cover on the starter motor assembly may be improperly installed, which can cause an electrical short during a crash.

  Remedy: Dealers will inspect and reinstall the starter motor terminal cover, as necessary, free of charge. Owner notification letters were mailed beginning October 22, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 285. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 4, 2025.

• BACK OVER PREVENTION:DISPLAY FUNCTION

  Hyundai Motor America (Hyundai) is recalling certain 2024-2025 Santa Fe and Santa Fe Hybrid vehicles. The rearview camera may not have been installed properly, which can damage the wiring harness and cause the rearview camera image not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

  Remedy: Dealers will replace the camera wiring harness, free of charge. Owner notification letters were mailed beginning January 15, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 288. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 22, 2025.

• AIR BAGS:SIDE/WINDOW:CURTAIN

  Hyundai Motor America (Hyundai) is recalling certain 2025 Tucson, 2025-2026 Santa Cruz, Santa Fe, Santa Fe Hybrid, and 2026 Genesis GV70 vehicles. The side curtain air bags may not have been installed properly, which can cause the air bags not to deploy as intended.

  Remedy: Dealers will reinstall the side curtain air bags, free of charge. Owner notification letters were mailed beginning December 29, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's numbers for this recall are 289 and 029G. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 22, 2025.

• SEAT BELTS:FRONT:ANCHORAGE

  Hyundai Motor America (Hyundai) is recalling certain 2023-2025 Hyundai Ioniq 6, 2023-2026 Genesis G90, 2024-2026 Hyundai Santa Fe, and Hyundai Santa Fe Hybrid vehicles. The driver and passenger seat belt anchors may detach.

  Remedy: Dealers will inspect and reinforce or replace the seat belt anchors, as necessary, free of charge. Owner notification letters were mailed beginning May 29, 2026. Owners may contact Hyundai customer service at 1-855-371-9460 and Genesis customer service at 844-340-9741. Hyundai's numbers for this recall are 298 and 032G. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov April 8, 2026.

2025 Hyundai Santa Fe safety ratings

Source: NHTSA NCAP ratings.

2025 Hyundai Santa Fe owner complaints (15)

• VISIBILITY/WIPER

  I am reporting a potential safety defect involving repeated windshield chipping and cracking on my 2025 Hyundai Santa Fe. The vehicle was purchased new. The first incident occurred on April 15, 2025, approximately three months after I purchased the vehicle. While driving approximately 60 mph on a highway in clear, dry conditions with no gravel or unusual road conditions, a small rock struck the upper-right portion of the windshield. The windshield cracked from the impact. The windshield was subsequently replaced on June 6, 2025. In June 2026, while again driving approximately 60 mph on a highway under clear and dry conditions, a small rock struck the center of the windshield and caused a chip. In July 2026, approximately one month later, another small pebble struck the upper-middle portion of the windshield and caused another chip. There were no crashes, sudden braking, turning maneuvers, or unusual driving conditions involved in these incidents. I am concerned because the windshield has repeatedly chipped or cracked from relatively small rocks or pebbles. I have owned and driven other vehicles for many years and have never experienced this level of repeated windshield damage from minor road debris. The windshield was supplied by Hyundai. I believe the repeated failures warrant investigation into the quality, durability, material, manufacturing, or specifications of the windshield glass used in this vehicle. The windshield is an important safety component, and a chip can potentially develop into a larger crack and impair the windshield's integrity while the vehicle is being driven. I have photographs of the most recent chip and an invoice documenting the windshield replacement performed on June 6, 2025. I am requesting that NHTSA review this complaint and determine whether similar complaints exist and whether a safety-related defect or trend may be present in the 2025 Hyundai Santa Fe.

• POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  While operating the vehicle, the vehicle suddenly began severely hesitating and stalling. During the incident, engine RPM surged to approximately 6,000 RPM and accelerator pedal response became abnormal. The vehicle was not responding normally to accelerator input, which significantly affected the ability to operate the vehicle safely. The vehicle subsequently recorded diagnostic trouble code P0304 – Cylinder 4 Misfire Detected. The abnormal operation of the vehicle during the incident was also captured on video. The vehicle was taken to an authorized Hyundai dealership for diagnosis. The dealership has advised that because the condition is not currently occurring and they have been unable to duplicate the problem, they may be unable to diagnose or repair the vehicle. The safety concern is not simply an illuminated check-engine light or a stored P0304 code. The concern is the combination of severe hesitation/stalling, abnormal accelerator response, and the engine surging to approximately 6,000 RPM while the vehicle was being driven. The cause of the condition has not been identified and, at the time of this complaint, the vehicle has not been repaired for the underlying problem. I am concerned that this condition could recur without warning while accelerating, entering or crossing traffic, or traveling at highway speeds. A recurrence could result in an inability to accelerate normally, unexpected vehicle behavior, loss of normal vehicle operation, or a collision. Hyundai has been notified of the issue and I have requested further technical investigation of the engine misfire as well as the transmission/TCU and electronic throttle/accelerator systems due to the high-RPM event and abnormal accelerator response. I am submitting this complaint because this appears to be a potentially serious safety-related defect and I want NHTSA to have a record of the incident and determine whether similar stalling, high-RPM, acceleration, transmission, or engine-misfire.

• STEERING

  Multiple occasions of the ADAS lane centering system operating unsafely. The worst one was on a gentle left-hand curve on a concrete surfaced bridge at night. The system allowed the vehicle to slowly drift to the outside of the lane. When it was fairly close to the white line, it jerked the wheel back to the left and then released the steering to my control while pointed hard into the oncoming lane. It will do similarly during the day when approaching a center turn lane on the highway. Sometimes it will decide that it should be in the turn lane, will make a rapid input, and then return control to me, now pointed at the oncoming lane. When the vehicle returns control to me, it indicates it by making the steering wheel and lines in the HUD grey, no chime, no warning icon, just green to grey and release the wheel in whatever direction it's pointing. It also sometimes slows drastically for vehicles that have exited the highway when on cruise control or applies hard braking for vehicles in the other lane while in a curve on a hill. There are no lights or malfunction warnings and the vehicle self-diagnostic says everything is operating correctly.

• POWER TRAIN

  Auto had a very strong gas smell after arriving at work. Check the engine and underneath the car for leaks but no fluids on the ground or my garage. Smell persisted while out of town and made appointment for inspection. The dealer service man said it was suffering numerous leaks and we’re awaiting parts. Latest info was still leaks present and would advise after making certain no leaks persist.

• FUEL/PROPULSION SYSTEM

  Gas needle not going down took and dropped off at Lee Hyundai of Fayetteville North Carolina 28309 8/15/2026 picked it up 08/17/2026 They claim they drove it six miles but they didn’t told it was supposed to be that way sold we filled up when we left the dealer ship drove 78 miles needle still not moving

• POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM

  Hyundai Sante Fe Hybrid 2025 has a bad factory seal on the high voltage harness - hybrid battery connector that causes water to intrude the connector under normal conditions which can short the battery and pose a major safety issue. Hyundai is refusing warranty coverage of my shorted hybrid battery on my brand new 2025 Hyundai Sante Fe Hybrid stating “Flood” with no evidence of flood damage. My car experienced multiple P engine hybrid system faults on XXX and would not drive. I had it towed the Van Hyundai Carrollton on that date. They did not look at the car for over a week and it sat on their lot the entire time. On XXX they finally inspected it and claimed the car had been “flooded” and shorted the hybrid battery. The only evidence they provided was moisture in the high voltage harness. There were no water/silt lines, any other damage to any other components, and no evidence of any water anywhere else on the vehicle. The video they showed of the undercarriage only showed normal splash marks from driving. The car was never flooded/submerged. Any water/moisture found in the harness would have been due to a faulty/defective factory seal that should be impervious to water under normal operating conditions. No water/flooding/submersion damage would have been obvious of this. The dealership refused to provide any evidence and had no follow-up. One key aspect they refused to acknowledge was there was a massive rainstorm in [XXX] onXXX which was also the only rainstorm in the area in the previous 1-2 months. This happened while the car was on the dealer’s lot. The car had no issues with any water prior to being at Van Hyundai. A case was opened with Hyundai Corporate and the Dealship also lied stating the car wasn’t in their system until XXX, which is false as I have phone records, tow records, and appointments showing the 7/10 date, so corporate overlooked that. I disagreed with the dealerships diagnosis as it was a scapegoat finding putting all blame o INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• POWER TRAIN,ELECTRICAL SYSTEM,ENGINE

  What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle suffers from an intermittent, total engine stalling and propulsion failure. Without warning, the engine completely shuts down while driving and automatically drops the vehicle into "Accessory (ACC) Mode". The vehicle is fully intact, operational when it restarts, and is available for immediate inspection upon request How was your safety or the safety of others put at risk? This issue has occurred five total times in live traffic, severely risking the safety of the vehicle's occupants and surrounding drivers. The most recent and dangerous incident occurred on the freeway in heavy, stop-and-go traffic. A sudden, complete loss of power on a high-speed freeway leaves the vehicle entirely vulnerable to rear-end collisions, as it leaves no room or momentum to safely coast to the shoulder. Has the problem been reproduced or confirmed by a dealer or independent service center? No. The vehicle has been brought to an authorized Hyundai dealership five separate times specifically to diagnose this exact stalling issue. Because the failure is intermittent, dealership service technicians have been unable to replicate the problem during their test drives or resolve the root cause. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected five separate times by authorized Hyundai dealership technicians during the service appointments mentioned above. No police, insurance, or independent manufacturer representatives have inspected the vehicle yet, as the stalling has not yet resulted in a physical crash. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?There are absolutely no dashboard warning lights, check engine indicators, error messages, or mechanical symptoms prior to the failures. The engine shuts down instant

• SEAT BELTS

  After waiting a month (called in june car went in 7/28/26)for an appointment with my dealer for 2 recalls and a broken rear seatbelt the dealership has deemed my vehicle unsafe to drive and has impounded my vehicle for almost a week. They have to replace not only 1 rear seatbelts but ALL rear seatbelts. The original recall is for the front seatbelt.

• TIRES

  235/60R18 103H While driving the 1year old car, the tire pressure reading in the vehicle began to go down, upon exiting the vehicle it was determined that two holes blew through in the side wall of the tire. Thankfully, this was not as dangerous of a situation as it could’ve been as the car had just come off the highway and was traveling at a lower speed a residential neighborhood. The tire is not available, it was disposed at the place it was replaced at. There were no major tire stores open as it was a Sunday so it replacement tire had to be purchased from a local tire vendor.

• FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

  I am submitting a second and more urgent safety complaint regarding the Driver Monitoring and Driver Assistance systems in my vehicle. I previously reported this same core defect: the system falsely fails to recognize my face, sounds repeated warnings, and disables driving assistance while the vehicle is moving. Despite that prior complaint, the defect remains, and the seriousness of the danger has clearly not been recognized or addressed. This defect has now placed my life in immediate danger. While I was driving, the system falsely determined that it could not properly see my face. It sounded repeated warnings and then abruptly disabled driving assistance. That sudden withdrawal of assistance created a near-crash situation. I was attentive and was not experiencing a medical emergency. The danger was created by the system’s false detection and defective response. A safety system should reduce danger. This system detected a supposed problem and made the situation more dangerous by removing the assistance that was helping keep the vehicle under control. Had this occurred beside a concrete barrier, near stopped traffic, in a construction zone, on a curve, or next to a large truck, the result could have been a fatal collision. I could have been killed because of this system defect. When a driver cannot be verified, the vehicle should maintain lane control, reduce speed, activate hazard warnings, and perform a controlled safe stop. It should never abruptly withdraw assistance and create a more dangerous condition. I request that NHTSA investigate why a previously reported life-threatening defect remains unresolved and require Hyundai to correct this system logic before someone is seriously injured or killed.

• TIRES

  First tire blowout- 6/3/26- on Ohio turnpike tire just blew. No nails / no pothole/ no reason back passengers side Second tire blowout - 7/4/26 on laurel street Pittston ( paved road, hit small bump in road. Nothing unusual) tire just blew out. Front drivers side). No nails no reason) Third tire issue -7 /16/26 large bubble noticed on back drivers side . Going to try to drive it to get ANOTHER new tire. After investing this on the internet, this is a know problem with the pitelli scorpion tire on the calligraphy model. We were never notified . Recommendation in line is to Replace all 4 tires! We just patio 1300.00 for the other 2 new ones which are apparently not safe. We no have to get a tire We were lucky that the 2 blowouts did not cause us to get in an accident or cause injury to someone. It’s only a matter of time and hundai will have a major suit in their hands I am going to file a complaint with Hyundai and the attorney general and anyone else I can think of. People need to be warned and they need to pay for new tires tie me plus the ones I already replaced Ethan now need to get rid of. If you Google you will see this had been a known problem previously reported to Hyundai

• ELECTRICAL SYSTEM,ENGINE

  While driving on the on ramp to [XXX] the car completely stopped and all systems shut off. There were two dash lights that flashed quickly with one being the check engine light but I did not see the other long enough to identify it. The dealership could not reproduce the issue but has the car now and is doing a more thorough evaluation. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine stopped. Yes it is available How was your safety or the safety of others put at risk? Extremely dangerous as it came to a stop in the middle of the road. It was late at night so at that moment no one was behind me. Has the problem been reproduced or confirmed by a dealer or independent service center? no Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? no Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? no, the warning lights flashed on as the car died but disappeared once off. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• ELECTRICAL SYSTEM

  On [XXX] after spending the day at Henson Creek Golf Course in Fort Washington, MD, I returned to my vehicle and discovered that it had completely lost all electrical power and would not start. The vehicle exhibited no warning signs prior to the failure. Believing the issue to be related to the battery, I contacted AAA for roadside assistance. AAA attempted to jump-start the vehicle, but the jump-start was unsuccessful. The vehicle was subsequently towed on May 18, 2026, to Pohanka Hyundai in Capitol Heights, MD for diagnosis and repair. After approximately nine days, the dealership advised that the battery terminals had been secured and that no additional problem could be identified. On [XXX], the exact same issue occurred again; however, this incident was significantly more dangerous because it occurred while the vehicle was being driven. While traveling during morning rush hour through a busy intersection in Northeast Washington, DC, the vehicle suddenly and completely lost power without warning while in traffic. The vehicle stalled in the middle of the intersection, creating an extremely hazardous situation. Fortunately, motorists traveling behind me were able to stop in time, and no collision occurred. However, this incident could easily have resulted in a serious crash involving injuries or fatalities. The vehicle was towed to Ourisman Hyundai in Bowie, MD, where it is currently undergoing additional diagnosis. I am extremely concerned that this vehicle has experienced two complete electrical failures within approximately one month, including one incident that occurred while driving in heavy traffic. Because the dealership was unable to identify the root cause after the first incident, I am concerned that a serious defect may exist involving the vehicle's electrical system, battery system, wiring, power distribution system, or another component affecting vehicle operation and safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• ELECTRICAL SYSTEM,SEAT BELTS

  The contact owns a 2025 Hyundai Santa Fe. The contact received notifications of NHTSA Campaign Number: 26V218000 (Seat Belts) and 25V659000 (Electrical System); however, the parts to do the recall repairs were not yet available. The local dealer was contacted; however, the recall repairs were denied due to a lack of maintenance records with an authorized Hyundai Dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

• ELECTRICAL SYSTEM

  On June 24, 2026, my spouse was operating our 2025 Hyundai Santa Fe when the vehicle suffered a sudden, catastrophic, and total electrical failure while actively on the roadway. The vehicle was stopped at a traffic light when all propulsion power was instantly lost, the engine shut down, and all electronic systems—including the center infotainment screens and instrument cluster—went completely dark. Safety Hazard & Entrapment Incident: Simultaneous with the total electrical failure, the vehicle's electronic door lock system malfunctioned. The rear passenger doors and rear liftgate locked completely and could not be disengaged or opened from the inside by the passengers. Due to this total power loss and lock failure, my young daughters were trapped in the rear seats. My spouse was forced to climb over the center console from the front seat into the rear cabin to manually extract our children through the front doors. The family had to abandon the disabled vehicle in live traffic and walk down the roadway to reach a safe location. This constitutes a severe safety hazard involving both sudden loss of motive power on a public road and occupant entrapment due to safety lock/latch failure during an electrical short. The vehicle has been towed to Pohanka Hyundai of Capitol Heights for inspection.