2025 Hyundai Tucson

2025 Hyundai Tucson recalls (6)

• EQUIPMENT:OTHER:LABELS

  Hyundai Motor America (Hyundai) is recalling certain 2025 Tucson vehicles. The glove box air bag warning label may be missing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Remedy: Hyundai will mail owners the warning labels, free of charge. Owner notification letters were mailed October 4, 2024. Owners may contact Hyundai Customer service at 1-855-371-9460. Hyundai's number for this recall is 268.

• ELECTRICAL SYSTEM:WIRING

  Hyundai Motor America (Hyundai) is recalling certain 2025 Tucson and Santa Cruz vehicles. The console extension wiring assembly may be routed improperly, allowing the transmission to be shifted out of Park without applying the brake pedal.

  Remedy: Owners are advised to use the parking brake when parking the vehicle. Dealers will reroute the console extension wiring assembly, free of charge. Owner notification letters were mailed December 17, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 273.

• ENGINE AND ENGINE COOLING:CRITICAL FASTENERS

  Hyundai Motor America (Hyundai) is recalling certain 2025-2026 Tucson and Santa Fe vehicles. The connecting rod bolts in the engine may have been improperly tightened, which can cause a loss of drive power and engine damage, possibly resulting in an oil leak.

  Remedy: Dealers will replace the engine, free of charge. Owner notification letters were mailed October 23, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 281.

• AIR BAGS:SIDE/WINDOW:CURTAIN

  Hyundai Motor America (Hyundai) is recalling certain 2025 Tucson, 2025-2026 Santa Cruz, Santa Fe, Santa Fe Hybrid, and 2026 Genesis GV70 vehicles. The side curtain air bags may not have been installed properly, which can cause the air bags not to deploy as intended.

  Remedy: Dealers will reinstall the side curtain air bags, free of charge. Owner notification letters were mailed beginning December 29, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's numbers for this recall are 289 and 029G. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 22, 2025.

• FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

  Hyundai Motor America (Hyundai) is recalling certain 2025-2026 Santa Cruz, Tucson, Tucson Hybrid, and Tucson Plug-In Hybrid Electric (PHEV) vehicles. Software in the front cameras may cause the forward collision avoidance system to activate prematurely and unexpectedly apply the brakes.

  Remedy: Dealers will update the front camera software, free of charge. Owner notification letters are expected to be mailed July 17, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 302. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 20, 2026.

• ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

  Hyundai Motor America (Hyundai) is recalling certain 2025-2026 Tucson, Tucson Hybrid, Tucson Plug-In Hybrid Electric (PHEV) vehicles. Due to a software error, the instrument panel display may fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."

  Remedy: The instrument panel display software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters are expected to be mailed August 22, 2026. Owners may contact Hyundai's customer service at 855-371-9460. Hyundai's number for this recall is 304. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 25, 2026.

2025 Hyundai Tucson safety ratings

Source: NHTSA NCAP ratings.

2025 Hyundai Tucson owner complaints (15)

• FORWARD COLLISION AVOIDANCE

  It suddenly brakes with warning forward collection. Thought this car recall update the s/w for forward collision braking.

• FORWARD COLLISION AVOIDANCE

  The contact owns a 2025 Hyundai Tucson. The contact stated that while driving 35 MPH on the highway, the vehicle ahead was slowing down to come to a stop, and the contact depressed the brake pedal. The Forward Collision Avoidance system activated and the vehicle came to an abrupt stop. Due to the failure, the contact was rear-ended by the vehicle behind. No air bags had deployed due to the failure. A Police report was filed. There was no injury sustained. The vehicle was driven away from the scene. Prior to the failure, the contact had received notification of NHTSA Campaign Number: 26V316000 (FORWARD COLLISION AVOIDANCE); and associated the failure with the recall. Neither the dealer nor the manufacturer was notified of the failure. The contact had taken the vehicle to an independent mechanic for an estimate for the repair of the vehicle. The vehicle was not yet repaired. The failure mileage was approximately 6,000.

• ELECTRICAL SYSTEM,EXTERIOR LIGHTING

  Two instances of the center screen malfunctioning. One was an intermittent blip of the screen turning black and then turning back on while driving. Additionally, during this same instance of the intermittent blip of the screen turning off for about 3 seconds, my headlights which are set to auto also turned off while I was driving at night and then blipped back on when the screen came back at the same time. Second instance, the center screen was black and never came on when the car was initially turned on and the screen remained black for the entirety of my drive until the car was fully turned off and then back on. Yes, this is available for inspection upon request. Safety was put at risk by losing headlight visibility at night highly increasing the chances of an accident as well as losing important carplay navigational directions on center screen. Problem has been reproduced as these issues both occurred within one week (the week of August 16-23, 2026). The vehicle has not been inspected. During the time of both events there were no warning lamps or messages that appeared.

• ELECTRICAL SYSTEM

  The instrument cluster malfunctioned suddenly leaving the control panel completely black (no odometer, speedometer, speed range, turn signal indicators, etc.). The driver was therefore unable to know what speed they were driving, how much fuel remained, and lacked any sort of signal that turn signals/blinkers were on or off. It was unsafe to drive and impossible to accurately comply with legal speed limits. Local Hyundai dealership inspected the car and confirmed that the cluster had to be replaced, which they did (required 11 total days of being unable to use the car).

• FORWARD COLLISION AVOIDANCE

  My 2025 Hyundai Tucson (VIN [XXX]) has been out of service since [XXX] (over 60 days) at CMA’s Colonial Hyundai in South Chesterfield, Virginia, waiting for a front camera related to safety Recall 302 (NHTSA Campaign 26V316 – Front View Camera FCA Update). The dealership previously replaced the front camera, but the issue was not resolved. They then ordered a new camera that remains on backorder with no firm ETA. I have been provided a rental during this time. Hyundai assigned Case #[XXX]. I have provided formal written notice under Virginia lemon law demanding a buyback because the vehicle has been out of service far beyond the 30-day threshold. The safety-related defect remains unrepaired. Components involved: Forward Collision Avoidance / Front Camera / Automatic Emergency Braking INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• ELECTRICAL SYSTEM

  COMPONENT: Infotainment main display screen. Still installed and available for inspection. FAILURE: The screen intermittently flickers, then goes blank with static. Occurs at unpredictable intervals including while driving. Ongoing and unrepaired. SAFETY RISK: The display is centered in the dashboard and houses the backup camera and vehicle controls. Flickering and static while driving creates a visual distraction, and the backup camera is unavailable when the screen goes blank. The malfunction now occurs often enough that it interferes with normal driving. REPRODUCED BY DEALER: Not reproduced during any service visit. Reported to three Hyundai dealerships: Pedder Hyundai, San Diego (May 2025): could not replicate, but accepted my video evidence and ordered parts. I relocated before the repair was completed. Hyundai Mountain View, CA ([XXX]): could not replicate. Declined to perform a diagnostic or open a warranty claim despite the same video evidence. Stevens Creek Hyundai, Santa Clara (Invoice [XXX], Aug 18-20 2026): road tested, unable to verify. Found stored code c2a2397, history in front camera menu. Infotainment software at current level. Road tested 94 miles without recurrence. Technician wrote: "If issue re-occurs, we recommend returning the vehicle to us for further diagnosis." No cause identified, no repair performed. Charged $315. I have provided video of the screen failing while driving to the dealerships and to Hyundai Motor America. INSPECTED BY MANUFACTURER: Inspected by the three dealerships above. Case opened with Hyundai Motor America Consumer Assistance in June 2026, unresolved with no written determination. Not inspected by police or insurance. WARNING LAMPS: None. No dashboard messages accompany the failure and it occurs without prior indication. First observed approximately May 2025, within weeks of delivery (delivered [XXX]). Current mileage 21,389. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• VISIBILITY/WIPER

  The windshield wipers will only go up once they have fully gone down all the way. Therefore, when snow (or something else) gets stuck below the windshield wipers while they are in use, they cannot go all the way down, and they will therefore not go back up again. The wipers become inoperable while trying to complete their cycle, and stay stuck in place creating extremely unsafe conditions. This incident occurred numerous times while in the snow, where a large chunk of snow or ice prevented the wipers from going all the way down, and the wipers would not work to remove additional falling snow until I pulled over and cleared the area below the wipers. I contacted HyundaiUSA and they said I had to go to dealer to address this issue, but the problem is not a manufacturing problem or broken part with my car, it is a design flaw that significantly impacts safety.

• WHEELS

  Vehicle: 2025 Hyundai Tucson SEL Mileage: Approximately 14,500 miles Tire: Original factory-installed 235/60R18 Incident Date: August 13, 2026 Time: Approximately 2:24 PM Location: US 751 near Garrett Road, North Carolina Injuries: None At approximately 2:24 PM on August 13, 2026, a 2025 Hyundai Tucson SEL with approximately 14,500 miles experienced a sudden front driver’s-side tire blowout while being driven on US 751 near Garrett Road in North Carolina. The vehicle was equipped with the original factory-installed 235/60R18 tires. The tire failed suddenly while the vehicle was being driven, creating a significant safety concern and potential loss of vehicle control. No injuries were reported. I went to the location to assist. Initially, I believed the damage was limited to the tire. The damaged tire was replaced so the vehicle could be driven safely, and the tires were subsequently replaced at a tire shop. After the incident, an unusual and persistent noise developed from the front driver’s-side area. Because the noise continued after the tire replacement, the vehicle was taken to a repair facility for further inspection. The vehicle is currently at the repair facility, and I am waiting for the inspection and repair findings. I do not yet have the mechanic’s final diagnosis regarding the source of the noise or whether there is additional mechanical damage. The front driver’s-side wheel/rim also sustained visible scratches and damage during the incident. I have photographs documenting the damaged tire and wheel, although the original damaged tire has already been replaced and is no longer in my possession. Given that the vehicle had only approximately 14,500 miles and the tire was an original factory-installed tire, I am concerned about the safety implications of a sudden tire failure on a relatively new vehicle. I am submitting this complaint to NHTSA so that this incident can be documented and evaluated for any potential safety issue or pattern involving t

• UNKNOWN OR OTHER,SERVICE BRAKES

  I was sold this vehicle as new. Then I look it up and it has these recalls. They should have to buy it back

• UNKNOWN OR OTHER,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE

  My 2025 Hyundai Tucson required the front brake rotors to be resurfaced at approximately 12,200 miles. The Hyundai dealership diagnosed the rotors as overheated and warped, despite the brake pads being in good condition. The repair occurred before Hyundai issued Recall 302 (NHTSA Recall 26V-316). Hyundai Recall 302 identifies a defect in the Forward Collision-Avoidance (FCA) system’s front-camera software that can cause the FCA system to engage earlier than expected and potentially result in sudden braking. Hyundai’s FCA system is capable of automatically applying the brakes. I am concerned that premature or unintended brake application associated with this recalled software condition may have contributed to excessive brake heat and premature overheating/warping of my front rotors. I am NOT claiming that this causal relationship has been established. Rather, I am reporting a potential safety defect and asking NHTSA to evaluate whether there may be a relationship. The dealership confirmed that the rotors were overheated/warped but characterized the condition as wear and tear. Hyundai Motor America subsequently denied my reimbursement request on the same basis. I have repeatedly asked Hyundai to evaluate whether Recall 302 could have contributed to the brake condition, but Hyundai has not acknowledged or technically addressed this potential relationship. The original rotors are no longer available for inspection because they were resurfaced during the repair. The dealership performed and documented the diagnosis and repair. I am submitting this complaint because I believe the combination of premature rotor overheating/warping at only 12,200 miles and a subsequently identified FCA defect involving unexpected braking warrants investigation.

• ELECTRICAL SYSTEM,EXTERIOR LIGHTING,FORWARD COLLISION AVOIDANCE

  The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at various speeds, the Forward Collision Avoidance Assist (FCA) warning light was intermittently illuminated. The dealer was notified of the failure and attributed the issue to inclement weather. The contact stated that while stopped, the vehicle was rear-ended because the brake lights failed to illuminate. The contact sustained lower back and shoulder injuries, was transported by ambulance to the hospital, and required ongoing injection treatments. A Police report was filed. The vehicle was towed to a dealer and repaired for rear-end and passenger-side damages; however, the cause of the brake lights' failure was not determined. Additionally, the contact stated that while attempting to accelerate from a complete stop at a traffic light, the vehicle stalled and was struck on the front driver's side by another vehicle. The crash caused the vehicle to spin, and the front end detached. The air bags failed to deploy, and a system failure message was displayed. The contact sought medical attention the following day. The contact sustained a dislodged left thumb bone which required surgery, a cast, and injections for left arm pain, as well as shoulder, neck, hip, and aggravated lower back pain. A Police report was filed. The second failure had occurred at [XXX]. The vehicle was towed to the auto body shop at the dealer and repaired; however, neither the dealer nor the insurance adjuster determined the cause of the vehicle stalling. The contact associated the failure with an unknown recall notification. The manufacturer was not notified of the failures. The failure mileage was unknown. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• FORWARD COLLISION AVOIDANCE

  This is not the first situation NOR the first time it is being "fixed". I took my car in early March for an oil change and informed the representative about the same thing. The time that made me say something is when I was switching lanes and the car must have sensed me being close causing me to stop completely and the car behind me having to hard break and swerve. Rick Case Hyundai in Duluth, Georgia had my car for a MONTH, just for me to experience the same thing over 3 times since then. I received my car in April, and the recall for this wasn't put out until May. I am constantly scared for my life and the passengers I may have lives, as well as the other drivers lives, considering I got this car due to being in a rear end collision. When I took it in April, they CONSTANTLY, drove my car to diagnose it but kept telling me they didn't see the problem, and it wasn't coming up for them on their internal tracking system for their cars(webDCS). Once they finally talked to the CORPORATE field technician, they advised they replace the whole front bumper, including sensors, for the solution. But like stated before, since then I have experienced near crash stops AT LEAST 3 times since then, two of them being in the same month (July 16 and July 28). If this is the same solution, I don't see it being beneficial and I would like to be bought out at this point. Especially if I have to be without my car for a long period of time again.

• FORWARD COLLISION AVOIDANCE

  I lease a 2025 Hyundai Tucson SEL. This vehicle has experienced repeated electrical and safety system malfunctions. Display/infotainment failure: The center display has shut off while driving on at least 10-15 separate occasions. This has occurred while I was actively using CarPlay for navigation in an unfamiliar area, causing loss of directions while driving. Forward collision/automatic emergency braking (AEB) malfunction: The AEB system engaged unexpectedly and unpredictably while I was driving on the highway, causing the vehicle to brake suddenly. This resulted in another vehicle rear-ending me. This occurred while I was driving home from a doctor's appointment. I understand this vehicle/system was subject to a manufacturer recall related to this issue. AEB failure to engage when needed: On a separate occasion, while I was backing out of a parking spot, the emergency braking system did not engage or respond when needed, and I narrowly avoided being struck (T-boned) by another vehicle. Warning system malfunction after repair: Following the highway incident, I brought the vehicle to an authorized Hyundai dealer, who performed a front safety system software update. Approximately two days later, while driving on the highway, a dashboard warning appeared related to the front safety system. This warning disabled cruise control and other related features. Dealer inspection/dispute: I brought the vehicle back

• FORWARD COLLISION AVOIDANCE

  The contact owns a 2025 Hyundai Tucson. The contact stated while driving at an undisclosed speed, the brakes independently activated. The contact stated that the vehicle decelerated to 60 MPH and the brake pedal was abnormally firm. The contact stated that the animals in the rear of the vehicle were thrown into the front seat of the vehicle. The contact stated that the seat warmer independently turned on, the touch screen activated and deactivated, and the oil change warning light illuminated. The contact received notification of NHTSA Campaign Number: 26V316000 (Forward Collision Avoidance). The vehicle was taken to the dealer; however, the failure was not duplicated. The contact was informed that the VIN was not associated with the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 7,000.

• UNKNOWN OR OTHER

  Infotainment cluster going black. Hyundai refuses to provide vehicle & won’t diagnose issue even after making appt.