2016 Jeep Grand Cherokee

2016 Jeep Grand Cherokee recalls (9)

• ENGINE AND ENGINE COOLING:ENGINE:DIESEL

  Chrysler (FCA US LLC) is recalling certain 2014-2018 Ram 1500 and 2014-2016 Jeep Grand Cherokee vehicles equipped with 3.0L diesel engines. The crankshaft position sensor tone wheel may delaminate causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.

  Remedy: FCA US will notify owners, and dealers will update the powertrain control module software to maintain vehicle propulsion by reading the camshaft position signal in the event that the crankshaft position signal is lost, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact FCA US customer service at 1-800-853-2002. FCA US's number for this recall is W58.

• ELECTRICAL SYSTEM:WIRING

  Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

  Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

• ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

  Chrysler (FCA US LLC) is recalling certain 2014-2019 Jeep Grand Cherokee vehicles equipped with the 3.0L EcoDiesel engines. The Exhaust Gas Recirculation (EGR) cooler may crack and allow pre-heated vaporized coolant to enter the EGR system. This mixture may combust inside the intake manifold.

  Remedy: FCA US LLC will notify owners, and dealers will replace the EGR cooler, free of charge. Dealers will also inspect and, as necessary, replace the intake manifold. Parts are not currently available. Owners were mailed an interim notification on December 21, 2021. A second notification will be mailed when parts are available, currently expected to be around March 11, 2021. The recall began March 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W79.

• ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

  Accessible Technologies, Inc. (ATI) is recalling certain ProCharger Superchargers, model numbers AB037A-100, AB037A-100P, and A037A-100B, sold for installation on 2012-2017 Jeep Grand Cherokee SRT8 and SRT vehicles. The supercharger mounting bracket may contact and damage the ABS line, possibly resulting in a brake fluid leak.

  Remedy: ATI will notify owners and will replace the supercharger brackets, free of charge. The recall began on December 12, 2017. Owners may contact ATI customer service at 1-913-338-2886.

• FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

  Chrysler (FCA US LLC) is recalling certain model year 2016 Dodge Durango and Jeep Grand Cherokee vehicles manufactured February 10, 2016, to April 28, 2016 and equipped with a 3.6L engine built at the Saltillo engine plant. During the assembly of the engine, the fuel rail crossover tube may have been damaged, which, over time, may result in a fuel leak.

  Remedy: Chrysler will notify owners, and dealers will inspect the engine assembly for damage to the fuel rail crossover tube, replacing it as necessary, free of charge. The recall began on December 23, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S85.

• SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

  Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Grand Cherokee and Dodge Durango vehicles manufactured December 9, 2015, to January 14, 2016. In the affected vehicles, the left front brake caliper may crack due to being made from an incorrect material.

  Remedy: Chrysler will notify owners, and dealers will inspect the front left brake caliper and depending on its casting date, replace it, free of charge. The recall is expected to begin on May 12, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S16.

• POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

  Chrysler (FCA US LLC) is recalling certain model year 2016 Jeep Grand Cherokee vehicles manufactured May 15, 2015 to February 19, 2016. The brake transmission shift interlock solenoid may have a loose electrical connection which could result in a loss of solenoid function.

  Remedy: Chrysler will notify owners, and dealers will replace the shifter assembly, free of charge. The recall began on May 27, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S28.

• FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP

  Chrysler (FCA US, LLC) is recalling certain 2014-2020 Jeep Grand Cherokee, and 2014-2019 Ram 1500 vehicles equipped with 3.0L diesel engines. A high pressure fuel pump (HPFP) failure may introduce internal debris into the fuel system, potentially resulting in fuel starvation.

  Remedy: Dealers will replace the HPFP, and inspect and replace, if necessary, additional fuel system components, free of charge. Interim notification letters informing owners of the safety risk were mailed July 21, 2022. Owner notification letters for were mailed for Jeep Grand Cherokee owners starting January 11, 2024. Owner notification letters for Ram 1500 owners were mailed March 7, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLS's number for this recall is Z46.

• ENGINE AND ENGINE COOLING

  Chrysler (FCA US, LLC) is recalling certain 2014-2019 Ram 1500 and 2014-2020 Jeep Grand Cherokee vehicles equipped with 3.0L Diesel engines. The crankshaft position sensor tone wheel may delaminate, causing the engine to lose its ability to synchronize the fuel injector pulses and cam shaft timing, possibly resulting in an engine stall.

  Remedy: Dealers will update the powertrain control module software to maintain vehicle propulsion, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 3, 2023. Some owner notification letters were mailed October 31, 2023. The remaining owner notification letters will be mailed at a future date, anticipated July 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 66A. This recall is an expansion of recall 20V-475.

2016 Jeep Grand Cherokee safety ratings

Source: NHTSA NCAP ratings.

2016 Jeep Grand Cherokee owner complaints (15)

• SERVICE BRAKES, HYDRAULIC,ELECTRICAL SYSTEM

  Abs module malfunctioned and caught on fire

• SERVICE BRAKES

  Brakes repetitively seize, causing the wheels to overheat and the vehicle to shake while braking, putting the vehicle at risk of fire, reduced brake performance, and brake failure. Two different dealerships have confirmed from the problem at various points, the brakes are "repaired" and then have the same failure with the same components again. There are no warnings that the brakes are seizing other than the smell of burning brakes, or smoke coming from the wheel.

• EXTERIOR LIGHTING,AIR BAGS,FORWARD COLLISION AVOIDANCE

  I hit a deer at 65 mph, causing significant damage to my vehicle, 7,300 to the front end. I have a safety beacon that detected the accident through my insurance, that detected the severity of the impact, resulting in an immediate call for safety to check on me. My airbags did not deploy, but there was a nasty aroma of sulfur during the impact. My minor children were secured safely in the vehicle, as well as myself. I, the driver of the car hit my head very hard on the steering wheel and window during impact, causing whiplash- neck pain, and reoccurring migraines still to this day 3-21-2026. Although I didn't receive medical attention it has been made known that I hit my head. This would've been avoided had my airbags deployed. I assume there may have been a malfunction and had this been a more serious incident, not only would my life be at stake, but most importantly my children. This is unacceptable for safety purposes.

• ENGINE

  The contact owns a 2016 Jeep Grand Cherokee. The contact stated that while driving approximately 60 MPH, the vehicle suddenly jolted, lost power, and went into LIMP Mode, almost causing a rear-end crash. The message "Service Electronic Throttle Control" was displayed. The vehicle was pulled over to the shoulder and inspected, but no cause was immediately determined. The vehicle was driven to the residence in LIMP Mode. The vehicle was taken to an independent mechanic, where codes associated with the crankshaft position sensor and intake manifold runner were retrieved, but the vehicle was not diagnosed or repaired. The contact associated the failure with NHTSA Campaign Number: 20V475000 (Engine and Engine Cooling). The manufacturer was notified of the failure. The failure mileage was 256,000.

• POWER TRAIN,FUEL/PROPULSION SYSTEM

  Tone wheel failure resulting in vehicle not operating as intended. Required repair of which FCA stated the repair was not covered by the recall issued against the vehicle.

• ENGINE

  Received a warning light and vehicle decelerated with a loss of power. After researching the issue it was determined that it was the crankshaft sensor that had become delaminated. Of which there is a current recall that would not be honored by FCA

• POWER TRAIN

  The contact owns a 2016 Jeep Grand Cherokee. The contact stated that while attempting to drive from a complete stop, the transmission remained stuck in first gear. The contact shifted to neutral(N) and shifted back to drive(D), and the vehicle responded as intended. There was no warning light illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 151,755.

• ENGINE

  The contact's son owns a 2016 Jeep Grand Cherokee. While the owner was driving at an undisclosed speed, the check engine warning light illuminated. The contact was informed that the vehicle had been running rough and idling roughly prior to the warning light becoming illuminated. The owner had taken the vehicle to a local dealer to be diagnosed. The dealer retrieved DTC: P0303 (Misfire in Cylinder #3). The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 129,045.

• POWER TRAIN,ELECTRICAL SYSTEM

  While driving then it just shuts off

• TIRES

  265/50R20 Cooper Evolution H/T, all 4 tires have cracks all the way around each tire, possibly sidewall defects. Tires were purchased new from Bob’s tire in Attalla, Alabama.

• UNKNOWN OR OTHER,ENGINE

  The transmission on this 2016 grand jeep Cherokee had completely went out due to fluids being in the transmission. Which is causing a head gasket problem as well. This car was regularly serviced. Only had this vehicle 7-8 months. My safety was put at risk when I was driving my kids to school and on my way to work when it started to overheat causing me to pull over and not being able to drive this vehicle. This jeep is currently at an authorized dealer and has been diagnosed. There were absolutely NO warning signs whatsoever to indicate that this vehicle was going to go out on me. I don’t think it’s fair for me to have to give up my vehicle for something that I did not cause!

• ELECTRICAL SYSTEM

  When I push on the gas pedal, sometimes the car revs up and the speed does not increase. I have to shut the car down and then restart. When I restart it, then it resets it in a way and I am able to drive. There is a hyperbola symbol that is seen on my dashboard that blinks when this happens. Please help.

• EXTERIOR LIGHTING

  Headlights will completely go out at night just at random, sometimes it's only one and sometimes it both completely. Yet the High beams and fog lights will work when activated even when the regular lights will not. Has been an ongoing issue for a while now, and upon talking to other Jeep Grand Cherokee owners of around the same year model they complain that there's do it randomly as well, and I've seen a lot of forums talking about this issue.

• AIR BAGS

  This 2016 Jeep Grand Cherokee was hit in the left front by a vehicle that failed to stop at a stop sign. It also spun and was impacted on the left rear as well. All airbags but the driver’s side curtain airbag deployed. The driver hit their head on the seat belt pillar on the driver’s side. I have contacted Jeep but they have not responded to me in over a week. Injury to the driver’s head would have been less traumatic if this airbag had deployed.

• ENGINE

  Oil filler neck leaking and possible due to a blown motor