2016 Ram 3500

STEERING:LINKAGES:DRAG:LINK:CONNECTION

Chrysler (FCA US LLC) is recalling certain 2013-2018 Ram 3500 and 2014-2018 Ram 3500 Chassis Cab and Ram 2500 vehicles. The outboard steering linkage jam nut may loosen, allowing one end of the drag link to separate.

Remedy: Chrysler will notify owners, and dealers will check the steering linkage jam nut tightness, replacing the drag link assembly or welding the nut to the adjuster sleeve, free of charge. The recall began March 22, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V06.

STEERING:LINKAGES

Streetcar ORV LLC (Streetcar) is recalling certain American Expedition Vehicles (AEV) 3" Dualsport aftermarket suspension kits, part numbers N0436000 and N0436001, sold for installation on 2013-2018 RAM 2500 and 3500HD trucks. Improper installation and machining of the original equipment steering knuckle may weaken the joint between the steering drag link and knuckle.

Remedy: Streetcar will notify owners and dealers will inspect and install a new steering knuckle, free of charge. The recall began December 3, 2018. Owners may contact AEV customer service at 1-248-926-0256, extension 500.

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

Chrysler (FCA US LLC) is recalling certain 2015-2017 Ram 1500, 2500 and 3500 pickup trucks equipped with an 8 foot bed and a power locking tailgate. Chrysler is also recalling all 2013-2014 and 2018 Ram 1500, 2500 and 3500 pickup trucks built before April 1, 2018 with a 6 or 8 foot bed and a power locking tailgate. On August 29, 2019 Chrysler expanded the recall to include an additional 693,128 model year 2013-2014 Ram 1500, 2500 and 3500 pickup trucks. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.

Remedy: Chrysler will notify owners, and dealers will repair the tailgate latch, free of charge. The recall began May 23, 2019. Chrysler is expected to notify owners of the expanded population on October 18, 2019. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's number for this recall is V44. Note: 2015-2017 MY Ram 1500 pickup trucks with truck beds other than 8 foot, are currently covered under NHTSA recall 18V-486 for this issue.

STRUCTURE:BODY:TAILGATE

Chrysler (FCA US LLC) is recalling certain 2015-2017 RAM 1500, 2500, and 3500 pickup trucks equipped with a power locking tailgate and either a 5 foot, 7 inch or 6 foot, 4 inch bed. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.

Remedy: Chrysler will notify owners, and dealers will repair the vehicle, free of charge. The recall began September 17, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U74.

ELECTRICAL SYSTEM:WIRING

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.

WHEELS:LUGS/NUTS/BOLTS/STUDS

Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.

Remedy: Dealers will update the torque specification in the owner's manual and other published service documents. Dealers will also inspect the vehicle's wheel studs, replacing them if necessary, free of charge. Owner notification letters were mailed on November 30, 2021. Campaign Y36 owner notification letters were mailed on November 30, 2021. Campaign Y26 owner notification letters were mailed on December 1, 2021. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's numbers for this recall are Y26 and Y36.

POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and 2010-2017 Ram 2500 and 3500 pickup trucks, all equipped with a column shifter. Pushing the brake pedal for prolonged periods when the vehicle is running and in PARK may cause the Brake Transmission Shift Interlock (BTSI) pin to stick in the open position. With the pin in the open position, the transmission can be shifted out of PARK into any gear without pushing the brake pedal or having the key in the ignition.

Remedy: Chrysler will notify owners, and dealers will update the vehicle software, inspect the BTSI, and, as necessary, replace it, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T79.

WHEELS

Streetcar ORV LLC, dba American Expedition Vehicles (AEV) is recalling certain 2013-2017 RAM 2500 and 3500 heavy duty trucks, modified by AEV to be equipped with cast aluminum Katla 8.5" road wheels. The outer surface of the wheel may fracture, resulting in rapid air loss.

Remedy: AEV will notify owners, and dealers will replace the wheels with wheels of similar value, free of charge. The recall began on August 30, 2017. Owners may contact AEV customer service at 1-248-926-0256 extension 500.

EQUIPMENT

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

AIR BAGS

Chrysler (FCA US LLC) is recalling certain model year 2013-2016 Ram 1500, Ram 2500, and 2014-2016 Ram 3500 vehicles. Certain driving conditions, such as driving off-road or debris striking the vehicle may cause the roll rate sensor to trigger a fault within the Occupant Restraint Controller (ORC). If this fault occurs, the rollover side curtain air bag and the seat belt pretensioner will be disabled from deploying.

Remedy: Chrysler will notify owners, and dealers will update the ORC software, free of charge. The recall began June 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T25.

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.

Remedy: Chrysler will notify owners, and dealers will replace the water pumps, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T51.

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

Chrysler (FCA US LLC) is recalling certain model year 2016 Ram 3500 trucks manufactured July 24, 2015, through January 7, 2016, and 2016 Ram 4500/5500 trucks manufactured July 24, 2015, through October 8, 2015. The transfer case may have been manufactured with a misshapen main output shaft, creating voids that may cause a shaft fracture.

Remedy: Chrysler will notify owners, and dealers will replace the transfer case, free of charge. The recall began on August 11, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S48.

ENGINE AND ENGINE COOLING:ENGINE

Chrysler (FCA US LLC) is recalling certain model year 2016 Ram 2500, 3500, 3500 Cab Chassis and 4500/5500 Cab Chassis trucks manufactured July 31, 2015, to August 13, 2015 and equipped with a 6.7L Cummins Diesel engine. In the affected vehicles, the Engine Control Module (ECM) may short circuit, causing the engine to stall without warning.

Remedy: Chrysler will notify owners, and dealers will replace the ECM, free of charge. The recall began on December 21, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R52.

EQUIPMENT

Chrysler (FCA US LLC) is recalling aftermarket Mopar Canvas Seat Covers for certain 2012-2016 RAM 1500, 2500, and 3500 trucks. These Mopar canvas seat covers were sold through Chrysler dealerships beginning October 15, 2015. The seat covers can impede the deployment of the seat thorax airbags.

Remedy: Chrysler will notify owners to remove the front seat covers and return them for a full refund. The recall began on July 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S30.

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

Chrysler (FCA US, LLC) is recalling certain 2016-2019 Ram 3500, Ram 1500, 2016-2020 Ram 2500, and 2016 Ram 3500 Cab Chassis vehicles. The right and left side curtain air bag inflators may rupture due to a manufacturing defect.

Remedy: Dealers will replace one or both side curtain air bags, as necessary, free of charge. Owner notification letters were mailed February 13, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's numbers for this recall are 05C, 09C, and 10C.

The contact owns a 2016 RAM 3500. The contact stated that when he took his vehicle to be aligned, he was advised that the vehicle was not able to be aligned, due to a previous recall repair where the drag link was welded unless the drag link was replaced. The manufacturer was notified of this issue. The failure mileage was approximately 55,526.

The contact owns a 2016 Ram 3500. The contact stated that when taking the vehicle to the dealer for recall repair for a drag link failure, from a previous owner, the vehicle was misaligned and the vehicle was unable to be serviced and could not be properly aligned. The vehicle was not repaired. The manufacture was not notified of the issue. The failure mileage was unavailable.

The contact owns a 2016 RAM 3500. The contact stated that while her husband was driving on several occasions at various speeds, the vehicle lost power and did not accelerate as intended. The vehicle was not diagnosed or repaired. The contact stated that her husband hooked the vehicle up to a handheld diagnostic machine where codes: P003A, P006a, P0046 populated. The manufacturer was notified of the failure. The failure mileage was approximately 74,500.

The contact owns a 2016 Ram 3500. The contact stated that while driving approximately 70 MPH, the steering rack fractured, and the contact was no longer able to maneuver the vehicle. The contact strapped the steering wheel into place to maneuver the vehicle. No warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the steering rack needed to be replaced; however, the cause of the failure was not known. The vehicle was not repaired. Another dealer was contacted and confirmed that the steering rack needed to be replaced and assisted the contact with finding the parts to repair the vehicle. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 275,000.

Took vehicle to dealership for repair of heater. Once the repair was complete the dealership called to say the heater was fixed but the airbag light is now on. Once doing more testing they called back to say my steering wheel airbag harness either shorted or was crushed during the heater repair The part is no longer available and no remedy was available. I just have to take my car back compromised I refused the vehicle back and requested management get involved.

I have a complaint that needs to be addressed. On Sept. 11 2025 I had a fire in the cab of my 2016 Ram 3500 truck while it was sitting in my drive way. It was not even running. The fire was not very big and it could have been repaired. So I called FCA and opened a case with them. They informed me that I needed to bring my truck into the closest dealership so that it could be inspected. So I then called and set up and appt for Sept. 12, 2025. I had my truck towed to the dealership and upon arrival my husband who took the truck was told to take it off the trailer. So they took it off the trailer. They informed me that a woman went to the truck, opened the door and stated “ well that’s a gonna be a total loss,” closed the door and had told them to move it to the fence line. She then stated that there was nothing that y’all could do for us and that it would cost me $350.00 to be diagnosed. At this time she already knew that I had an open case with FCA and that I was told to take it in. Upon walking to the truck when my husband opened the door and it had caught fire again. So he went and told some employees in the service dept and they ran out to the truck and disconnected the batteries. Then we were told that we needed to take it off the lot if we weren’t going to pay. So they reconnected the batteries and we put the truck back on the trailer and brought it home. The next day my truck was completely engulfed in flames along with my husbands welder which is used for our business. I called FCA back on Monday and spoke with my case manager/inspector and let them know about the two fires after the first and he stated he would be going to inspect the following day. He then asked if the truck was at the dealership and if the batteries had been disconnected by your employees. I stated no the truck is here at my home and the batteries were reconnected so that we could tow it out of the dealership since that’s what we were told to do. I have told the dealership and no response

On Sept. 11, 2025 my truck parked in my drive way. It was parked there all night. When I opened the doors to get in smoke and flames started coming out. The center console was on fire. The next day on Sept. 12, 2025 while at the dealership to have the truck inspected it caught fire again further burning the center console, the passenger seat and the roof. The dealership told us there is nothing they could do so we had to have the truck towed back to my home. Sunday night on Sept. 14,2025, I heard a loud pop noise and when I walked outside the entire cab of the truck was engulfed in flames. We had to call the fire department and they had to come put the fire out. Each of the incidences started spontaneously when the truck was just sitting parked.

The parking brake issue per recall was supposedly done based on information from safetycar. Vehicle can not be shut off unless in park. I'm assuming a safety feature. A few times when I attempted to shut off,even though clearly in park. Truck wouldn't do so. I shifted back into gear and then back into park with foot on brake as required. Unless I have a horse trailer hooked up, I usually don't engage parking brake if on relatively flat surface. Last week I came out to find my truck still in park had rolled forward and got caught on a large boulder before potentially rolling all the way down into a creek and pond. The boulder did do undercarriage damage mostly to brackets for bumper and spoiler. When I got in truck IT WAS STILL IN PARK. Truck started without me stepping on brake as required. Then after it started,I couldn't put it into gear. Was like shifter was locked. I tried to shut it off it wouldn't shutoff until I applied brake. I started it again with foot on brake and then I was able to shift into reverse and drive. Something is definitely wrong with the park on truck. It rolls forward now a few inches when parked and shut off in park. It will start sometimes without foot on brake and sometimes not. Since it rolled and hit rock steering feels weird. Prior to vehicle rolling and the bogus drag link fix, I have gone through tires because you can't do a full alignment. Dealership claims there's no new fix. They just won't do it right. Just like park brake issue it's not fixed right. Dealerships also claim they know nothing about a new issue and another fix. There are kids around horse farm truck coming out of gear,even though it said park,could have been a fatal accident. This truck has turned into a death trap waiting to happen and Stellantis and FCA won't acknowledge. I have to pay for a fix when it's their issue. THE 67A update has cost me over $12,000 already. THIS TRUCK SHOULD BE BOUGHT BACK BEFORE SOMEONE GETS KILLED. PARK BRAKE APPLIED ALWAYS.

Odometer Fraud. The contact's husband owns a 2016 Ram 3500. The contact stated that her husband was recently interested in trading in the vehicle. While on Facebook Marketplace, a person interested in vehicle requested a Carfax report of the vehicle. Upon obtaining the Carfax report, the contact discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 167,000; however, the Carfax report discovered that back in 2022, the vehicle mileage was 370,000.

Def pump failed, I had to have it replaced before it degraded my travel speed to 5 mph. After spending $250 to Dodge dealer in Oxnard Service department for them to tell me exactly what it said on the truck code DEF pump needed replacing, I decided I didn't want to spend an extra $1000 for the dealer to fix it ($3900 they wanted for this job). On 11/16/22, I paid ($2865.81) to a reputable diesel mechanic to replace the pump. I was denied the reimbursement that was promised in the recall information. I need help with this! I pay $1200/ month for truck and insurance, but Ram can't reimburse me for a recall I paid out of pocket for, as promised. ABSOLUTE CROOKS! I want help with this. I see there are multiple other complaints of the same issue! HELP!

I am writing to report an ongoing issue with my 2016 Ram 3500 (V6), related to Safety Recall V06 (NHTSA 19V-021) for the drag link, which was performed in 2020 before I purchased the vehicle two years ago. The recall "fix" involved welding the adjustable nuts on the steering linkage, rendering it non-adjustable. Since then, I have been unable to get a proper front-end alignment at any service shop. Multiple mechanics have refused to perform an alignment because the welded drag link cannot be adjusted, and they’ve stated it compromises the vehicle's steering integrity and tire wear. This is a significant safety concern. Without the ability to align the front end, the vehicle’s handling is affected, potentially leading to uneven tire wear, reduced control, or worse, a steering-related failure. I’ve contacted dealerships and Chrysler (FCA US LLC), but they insist the recall was completed and offer no further remedy, despite the fact that this weld does not allow for standard maintenance. New Ram 3500s off the assembly line come with adjustable drag links, not welded ones, which proves this was a poor fix for a safety issue. I urge the NHTSA to revisit this recall and require Chrysler to replace the defective drag link with a proper, adjustable component, rather than leaving owners like me with a substandard repair that hinders basic vehicle maintenance and safety. I purchased this truck in good faith, but this unresolved issue has made it a liability. Please investigate and address this matter before it leads to more serious consequences.

" The Hydraulic Control Unit Chrysler part number 68143491AA failed and been replaced multiply times on my vehicle. I have the current failed part available for inspection upon request. This causes the Anti-lock braking system, Traction control system, Park Assist and Cruise Control to no longer function properly. This puts the driver and others at risk. Lights came on while the truck was not in motion and was just started. Lights first came on 9-2-24 and have been on and off since then. The problem has been reproduced by my local dealer twice both with the original part and its' replacements. The vehicle/component has not been inspected by the manufacturer, police, insurance representatives or others. There were no Warning lamps/messaged before failure only after. These would be ABS lamp and traction control lamp plus a service ABS and electronic braking system warning message.

Upon shifting into reverse the rear tailgate backup camera operates intermittently causing me to loose rear visibility directly behind truck. When this occurs the Uconnect displays a fuzzy & distorted image as if there’s signal interference. Opening & closing the tailgate sometimes alleviates this issue but only temporarily.

The contact owns a 2016 Ram 3500. The contact stated that upon inspection, the tires showed excessive wear. The contact stated that the vehicle had been previously repaired under NHTSA Campaign Number: 19V021000 (STEERING); however, the recall repair failed to fix the vehicle. The contact stated that the failure persisted after the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 78,000.

My def pump failed. Paid for repair. Now they have a recall for the part. I submitted a claim they denied my claim because I didn't have download 67a done before repair download wasn't available at that time. My truck is in the milage and dates required. I need help