2019 Tesla Model 3

2019 Tesla Model 3 recalls (21)

• ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

  Remedy: Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.

• SUSPENSION:CRITICAL FASTENERS

  Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.

  Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.

• ELECTRICAL SYSTEM:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.

• SEAT BELTS

  Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.

  Remedy: Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.

• ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK

  Tesla, Inc. (Tesla) is recalling all 2017-2020 Model 3 vehicles. The rearview camera cable harness may be damaged by the opening and closing of the trunk lid, preventing the rearview camera image from displaying.

  Remedy: Tesla Service will inspect and install a guide protector and new cable harness as necessary, free of charge. Owner notification letters were mailed April 24, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-17-008.

• SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

  Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.

  Remedy: Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.

• FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: CAMERA

  Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.

  Remedy: Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.

• EQUIPMENT:OTHER:LABELS

  Tesla Motors, Inc. (Tesla) is recalling certain 2019 Tesla Model 3 vehicles. The driver-side sun visor may not have the required air bag warning information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

  Remedy: Tesla will notify owners, and Tesla Service Centers will inspect the visor and replace it, as necessary, free of charge. The recall began December 6, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-15-003.

• ELECTRICAL SYSTEM:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

  Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.

• BACK OVER PREVENTION:DISPLAY FUNCTION

  Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model S, Model X, and 2017-2020 Model 3 vehicles equipped with Autopilot Computer 2.5 and operating certain firmware releases. The rearview image may not immediately display when the vehicle begins to reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed May 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-004.

• ELECTRICAL SYSTEM:SOFTWARE

  Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

  Remedy: Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.

• ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

  Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."

  Remedy: Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.

• VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

  Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

  Remedy: Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.

• SEAT BELTS:REAR/OTHER:ANCHORAGE

  Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.

  Remedy: Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.

• STEERING:AUTOMATED/ADAPTIVE STEERING

  Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation.  The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

  Remedy: Tesla will release an over-the-air (OTA) software update, free of charge.  Owner notification letters were mailed April 15, 2023.  Owners may contact Tesla customer service at 1-877-798-3752.  Tesla's number for this recall is SB-23-00-001.

• SUSPENSION:FRONT

  Tesla, Inc. (Tesla) is recalling certain 2018-2019 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.

  Remedy: Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-31-001. This recall is an expansion of previous recall number 21V-835.

• ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING:SOFTWARE

  Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

  Remedy: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.

• ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

  Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

  Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

• FORWARD COLLISION AVOIDANCE: WARNINGS:EXTERNAL/PEDESTRIAN ALERT

  Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

  Remedy: Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.

• SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

  Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

  Remedy: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.

• TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

  Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

  Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.

2019 Tesla Model 3 safety ratings

Source: NHTSA NCAP ratings.

2019 Tesla Model 3 owner complaints (15)

• AIR BAGS,SEAT BELTS,SEATS

  It was raining and my passenger got in the car (slightly damp). When he sat down, I reveived an error message on the screen saying "Front passenger safety restraint system issue". The airbag light is red indicating that it won't work for my passenger. You should be able to get into a car wet without your airbag no longer working. My understanding is that this is a common problem. Tesla wants > $1000 to replace the seat sensor + requires me to pay to have my airbag replaced so the part matches the sensor. According to Tesla Service Bulletin SB-23-20-002, the new style of seat sensor is strictly incompatible with the older style of airbag (known as a "Full Suppression" airbag). $182 (Diagnostic Fee) $475 (OCS Replacement) $318 (Airbag Update) + Labor + Tax The internet is full of reports of this issue. Just google "Front passenger safety restraint system issue". I do not have an invoice for the repair yet. Tesla's service center's first available appt is in 25 days. This means I have to go 25 days without a passenger in my front seat.

• FORWARD COLLISION AVOIDANCE

  I was using Full self driving (FSD), but I notice the autopilot gets "impatient" when (correctly) stopped for a "long" period of time (~2 minutes), but will then try to proceed in dangerous conditions. 1. I had FSD engaged while waiting to make an uncontrolled left turn. The street I'm turning onto is busy, so both lanes are going at a steady pace. After about 2 minutes of waiting, the autopilot decided to make the left turn while BOTH directions had cars approaching. It turned towards a motorcyclist (which might be why it thought the lane was "empty"), and cut off a rather large car behind the motorcycle which almost caused a collision. I was honked from both sides (rightfully so) and put in a very dangerous position as my car was now stopped in the middle of the row of both lanes. 2. I was at a red light intersection with no traffic coming from either side with FSD engaged. After about 2 minutes of waiting, the car tried to go on its own while the light was still red. After manually stopping the autopilot, the light naturally turned green a few seconds later.

• AIR BAGS,SEAT BELTS

  Our seatbelts and airbags required replacement as Tesla stated safety equipment on a Tesla is only guaranteed until 60,000 miles and after that they often need repairs. It was quite expensive. The seatbelts and airbags total cost was $1296.40 and already the Tesla says the front passenger airbag needs to be replaced again.

• SUSPENSION

  these cars have a defective control arm system and they are prone to messing up over and over, they have replacement revisions but try to charge you for labor and parts if youre out of warranty even though they know the parts were a problem and revised them. Tesla does nothing to help you and will even try to charge you $200 just to diagnose the issue.

• STRUCTURE

  Component: Exterior Door Handle (Front Passenger) Incident Description: A latent manufacturing defect resulted in the structural delamination of the interior chrome plating on the front passenger door handle. This failure occurred after the last use of the handle, creating a razor-sharp metallic edge that was not visible during a normal approach to the vehicle. Upon contacting the handle to open the door, a passenger sustained a deep laceration from this jagged metallic blade. Safety Hazard: The defect transforms a primary vehicle touchpoint into a concealed cutting hazard. The chrome skin peels and curls into a sharp edge without warning or visible signs of wear, posing an ongoing risk of serious physical injury to any occupant. Manufacturer Response: Tesla Service (Los Gatos) was provided with photographic evidence of the razor edge and the resulting injury. While acknowledging the injury, Tesla refused a safety-based "goodwill" repair, citing the vehicle’s age (2019) and the absence of a formal recall. Tesla further attempted to attribute this structural material failure to cleaning products, despite the vehicle being garage-kept and maintained only with pH-neutral enthusiast-grade soaps. Tesla has since refused further discussion. Request: This defect poses an ongoing risk of serious physical injury to any occupant using the handles. I am reporting this to assist in identifying a trend of material failure in 2017–2020 Model 3 chrome door handles.

• FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

  Tesla FSD on HW3 vehicles has become very unstable. Users complain the car ping pongs within the lane and occasionally will steer onto the left or opposite lane. This seems to have happened after a recent update between Feb/March 2026. Growing reports of the same issue reported on Reddit. Ping pong tesla fsd Sources: r/TeslaFSD, r/TeslaLounge, r/TeslaSupport Tesla FSD Ping Pong Effect Software Updates Recent Updates: Many users have reported that the ping-pong effect started after recent software updates, particularly 2026.8.6 and 2026.14.3. "Yes, this started for me after the update to 2026.8.6 and continued on 2026.8.6.1" HW3 Issues: Some users with Hardware 3 (HW3) have noted that FSD has become unusable due to this effect. "I'm HW3 Software 2026.14.3 FSD Software V12.6.4 Driving on the highway is completely unusable and would result in a crash if I kept it on." Troubleshooting Steps Camera Calibration: Several users have suggested recalibrating the cameras, which can sometimes help. "Try a camera housing cleaning and a camera calibration" DAS Reset: Performing a Driver-Assist System (DAS) reset has also been recommended. "Also reset the DAS" Cleaning Cameras: Ensuring the cameras are clean can improve performance. "Ask SC or mobile service to check camera alignment AND clean the front cameras, and recalibrate cameras." Hardware Issues IMU/Gyroscope: A few users have been told by Tesla service that the issue might be due to a failing gyroscope/IMU in the HW3 Autopilot computer. "The tech told me it might be a failing gyroscope/IMU inside the HW3 Autopilot computer." HW3 Replacement: Replacing the HW3 computer can be costly, and some users are considering waiting for a HW4 retrofit. "Their solution is to replace the entire HW3 computer — quoted around $2,500–$3,000." User Experiences Ping-Ponging on Highways: Many users have reported the ping-pong effect specifically on highways. "While using FSD on higher speed interstates (multiple) my car acts like a

• ELECTRICAL SYSTEM

  The contact owns a 2019 Tesla Model 3. The contact stated that while the rear seat warmer was active, a hole had burned through the seat due to the heat coming from the seat warmer. The contact stated that a blanket was placed over the seat which caused the blanket to melt and fuse into the seat. As a result of the failure, the contact had to tear apart the back of the seat where the failure occurred. The contact spoke to a Tesla service technician who gave the contact an estimate for the repair. The vehicle was not repaired. The failure mileage was approximately 78,000.

• UNKNOWN OR OTHER,BACK OVER PREVENTION

  There was a failure of a rear camera to detect the proximity of a closed garage door when in reverse in a driveway. The result was hitting the garage door and damaging the garage door as a result. This could be dangerous as there was no warning on the backup camera screen and no audible warning. This was a very expensive repair given the garage door was a unique color and design.

• AIR BAGS

  I am submitting a complaint regarding a “Front Passenger Safety Restraint System Fault” warning that recently appeared on my Tesla vehicle. My vehicle currently has approximately 45,000 miles. This warning indicates a potential issue with the passenger airbag or related restraint system components, which is a critical safety feature. A malfunction in this system raises serious concerns about whether the passenger airbag would deploy properly in the event of a crash. I contacted Tesla service, and I was informed that the repair would cost over $1,500 out of pocket. Given the relatively low mileage and the importance of the safety system involved, I am concerned that this may represent a broader defect rather than normal wear and tear. Additionally, I have found similar reports online from other Tesla owners experiencing the same warning, which suggests this may not be an isolated incident. A failure or malfunction of the passenger restraint system presents a significant safety risk to occupants. I believe this issue warrants further investigation to determine whether there is a systemic defect affecting Tesla vehicles. I am requesting that NHTSA review this issue and consider whether further action, including a potential recall or manufacturer responsibility, is appropriate. Vehicle details (VIN, model, year, etc.) can be provided as needed.

• AIR BAGS,SEAT BELTS

  The car was giving me a warning "Front Left Restraint System Fault" (RCM_a021) approximately for 4 months (Jan 2026?) - I brought the car in for service April 2026 and after researching, the technician found that there was a failure in the wiring harness - this is the wiring harness that is responsible for the seatbelt pretension mechanism that activates in a accident. The technician had to replace the harness for the issue to resolve. However, it's my understanding that, had an accident occurred prior to the repair, that the safety system would not have operated properly.

• SERVICE BRAKES

  The Tesla was hit on the passenger side by a Honda civic that ran a red light traveling more than 25 mph The Tesla spun 180 degrees after impact. No airbags deployed. Immediately after impact the Tesla turned on hazard lights. However the vehicle would not come to a stop after pressing on the brakes. After impact the vehicle was coasting backwards at probably less than 5-6 mph. It would not respond to brake presses. Oddly the vehicle had regen braking enabled which should have brought it to a stop, but it didn’t. The vehicle kept coasting backwards as if it was in neutral for about 20 meters until it hit a curb and stopped. BRAKES WOULD NOT WORK!!!

• AIR BAGS,SEAT BELTS,SEATS

  I received a notice onscreen (photo attached) that says "Front passenger safety restraint system issue, Service is required." I did some research online and a number of other owners of 2019 Tesla Model 3 vehicles have received this warning, which involves a malfunction that is a combination of the front passenger seat belt, air bag, and seat sensor for the air bag. A number of people with this year and make have gone to Tesla, and Tesla service workers have said "this a known issue" for this year and make. Since this issue involves a number of safety components, and is a known issue, Tesla should be required to fix this as a product defect recall. Instead, they quoted multiple owners, including myself, approximately $2,000 to fix.

• VEHICLE SPEED CONTROL

  The contact owns a 2019 Tesla Model 3. The contact stated that while the vehicle was stopped at a residential gate, the vehicle unexpectedly accelerated. There was no warning light illuminated. The vehicle was towed to a private residence. No warning light was illuminated. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.

• STRUCTURE

  The chrome lamination/sticker is peeling from the underside of the door handles. This peeling causes an extremely sharp edge that cut my finger. This issue is noted rather constantly over the internet. The sharp edge is hidden by the retracting mechanism of the door handles, and so you don’t see it until you grab it and cut yourself.

• SEAT BELTS,SEATS

  An error message appears every time my husband drives. Whenever he moves the driver seat backwards, “Front left safety restraint system issue” message appears on the display screen.