2016 Toyota Corolla

2016 Toyota Corolla recalls (1)

• AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2011-2019 Corolla, 2011-2013 Matrix, 2012-2018 Avalon, and 2013-2018 Avalon Hybrid vehicles. During certain crashes, the air bag electronic control unit (ECU) may malfunction, possibly disabling the deployment of the air bags and/or seat belt pretensioners.

  Remedy: Toyota will notify owners, and dealers will inspect the ECU and install a noise filter between the air bag control module and its wire harness, as necessary, free of charge. Owners were notified of the safety risk beginning March 2, 2020. A second letter notifying owners of the remedy repair will be mailed between March 16, 2020 and June 27, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are 20TB03, 20TA03 and 20TA05.

2016 Toyota Corolla safety ratings

Source: NHTSA NCAP ratings.

2016 Toyota Corolla owner complaints (15)

• UNKNOWN OR OTHER

  The factory-applied Super White (paint code 040) paint on my vehicle has peeled down to bare metal on multiple exterior body panels. The peeling is not the result of any collision damage, scratches, or external trauma — it is consistent with the known factory paint adhesion defect that Toyota itself acknowledged through Customer Support Program ZKG, which covered this exact vehicle model, year, and paint color. Toyota's own program documentation states the defect occurs when sunlight degrades adhesion between the factory paint primer coat and the base metal electrodeposition layer. With paint peeled to bare metal, the affected panels are now exposed to moisture and the elements, creating a risk of structural rust and corrosion over time. I purchased this vehicle used in 2023 and was never notified of the Customer Support Program. By the time I discovered the program existed, the coverage had expired. Toyota has declined to provide any assistance. Toyota acknowledged this as a manufacturing defect affecting approximately 1.74 million vehicles under Program ZKG. Owners of 2016 Corollas who purchased their vehicles used were not adequately notified, and coverage has now lapsed for recently expired vehicles despite the defect being identical to those Toyota previously covered. I am requesting that NHTSA investigate whether Toyota's Customer Support Program ZKG adequately covered all affected vehicles and owners, and whether an expanded or extended remedy is warranted.

• POWER TRAIN

  I was driving on the highway and the transmission gave completely out!! with no warning! No check engine light no error message. Car only has 160000 miles on it, if i wasn't calm as I was that could've been lethal!!!!

• STRUCTURE

  I have super white (040) paint and it's flaking off due to original manufacturer paint defect. Paint is flaking off my passenger back door and a large piece/area of roof. flakes of paint will come off at highway speeds, creating a vision hazard for drivers behind me or a distraction when flakes hit the windshield.

• AIR BAGS

  In 2024, my 2016 Toyota Corolla was involved in a collision. The airbags did not deploy. I went to the emergency room following the crash and later required additional medical treatment, including rehabilitation.

• POWER TRAIN

  My 2016 Toyota Corolla suddenly showed a Check Engine light, and the dealer diagnosed a CVT transmission failure with code P2757. This code is linked directly to Toyota’s own TSB T-SB-0150-16 for torque converter clutch/valve-body failure. The dealer confirmed the issue and quoted me $11K to fix it. This is frightening because a failing transmission can slip, hesitate, or lose power at any moment, which puts me and others at risk. There were no early warning signs, just the sudden light. I brought it in immediately, and the problem was fully reproduced and documented by Toyota. My car is available for inspection whenever needed. Toyota corporate reviewed my case but offered very little help since my vehicle is just outside the 7-year timeframe for CA. I bought the extended warranty when the car was brand new. I have done every single service at Toyota, always on time, and my car has never been in an accident. I’ve taken care of it exactly the way Toyota told me to. This is not normal wear. This is a documented defect that puts drivers at risk and places an enormous financial burden on owners who did everything right. I’m filing this complaint because people deserve protection, accountability, and fairness, especially when a safety-related failure happens in a well-maintained vehicle. I’m only [XXX] , and I expected to own many more Toyotas throughout my life. My whole family drives Toyotas. I grew up believing this brand meant safety, reliability, and loyalty in both directions. I honestly wanted to be a Toyota driver for life. But facing an $11K repair for a known issue that Toyota already acknowledged in a TSB—without meaningful support—has broken my trust in a way I never expected. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• ELECTRICAL SYSTEM,AIR BAGS,SEAT BELTS

  The driver seat belt dont work and once in a great while it will work but even whenever it does latch it still shows the seat belt isn't on and that noise keeps going off but after a while the noise goes off but the symbol is still on the dash board. I recently got hit from behind (09/15/2025) at a red light and no air bags deployed. Im not sure if they were suppose to deploy but either way my seat belt dont work. And I know this isn't a safety matter but my radio doesn't turn off when I turn off my car and I can't lock/unlock my doors with the key fob I have to lock it with the key on the driver door. I have to take the fuse out for the radio so my battery won't die and so the radio turns off.

• ELECTRICAL SYSTEM

  Radio will constantly reset as well as the in-dash clock, and the Tire Pressure light will illuminate and flash. I found this appears to be a consistent issue with 2014, 2015, and 2016 Toyota Corolla's on YouTube.

• STRUCTURE,UNKNOWN OR OTHER

  At about 40000 miles on about [XXX] I noticed my paint starting to peel and fade from my roof as time passed it went to my hood and trunk faded and clear coat peeling I took my car to Toyota in Brownsville Tx and there was no recall on paint defect on roof but the associate told me they had 2 Toyota Corollas being fix on recall for same defect as my Red toyota Corolla but those cars are white I don’t understand why my red car with same defect wouldn’t fall under recall I have seen my self a green and blue Corolla on the streets with same issue I have paid my car clear I’m [XXX] can’t afford to paint and car has plenty of years for me but paint is look bad thank u hope for a repose or help INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• STEERING,POWER TRAIN

  The contact owns a 2016 Toyota Corolla. The contact stated while driving at an undisclosed speed, the vehicle downshifted with no warning light illuminated. The contact also stated that the steering wheel seized with no warning light illuminated. The contact stated that the steering wheel became difficult to turn. The vehicle was able to restart. The vehicle was taken to an independent mechanic, where it was diagnosed that the steering module and the transmission had failed and needed to be replaced. The vehicle was not repaired. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 43,000.

• STEERING,SUSPENSION,SERVICE BRAKES

  I recently 6 weeks ago bought a used certified 2016 Toyota Corolla with 43,000 miles. I have been going back and forth with Toyota since the day after I bought it about the many mechanical issues that pose a major safety risk. The car shudders/vibrates when accelerating, knocks when backing up. And when making turns the car shifts hard side to side with a shudder and wobble in floor board of car. It feels as if you don’t have control of the vehicle when driving. It has lots of loose play in the front end and steering really the whole car. It also has a problem going up hill and jumping on fwy a major problem accelerating. They keep telling me car is working per design but this is a lie. I have taken it to 2 other mechanics who told me this car has major issues safety ones to take it back. Toyota fixed the control arms stating that might be what it is but the same problems remain. I am afraid to drive this vehicle and they refuse to figure out the problems and fix them. 2 days after buying it I told them take the car back it has too many mechanical issues they refused. I don’t know what to do I cannot continue driving this car like this and in the rain it could barely handle also. The car has a feeling of loss of control like the whole frame of car is loose. I need help and don’t know what else to do I’ve taken the car back to them about 15 times. They continue to lie and say nothing is wrong even though when I test drove it with the head mechanic. He admitted the car has major issues but told me he did not want to get involved and I would have to take it up with management. I traded in my 2011 suv that was in good working order to buy this smaller car so my daughter could also learn to drive. They should have never sold this vehicle with this many mechanical safety issues please help.

• UNKNOWN OR OTHER

  There are no incidents but it is requiring me to fill this out.

• POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE

  We own a 2016 Toyota Corolla Sport model. 4 door sedan. We first started to notice a loud sound that was seemingly coming from the front of the car. It was a whining, rattling sound. The car's mileage is 87k. We took it into the shop, we were first told that it sounded like a bearing going out in the wheel. Then we took it to a licensed Toyota dealership. The dealership then tells us that it is actually due to the transmission chain, and our transmission will need to be replaced for $8900!! So I begin to dig online, and find that our model is the same years of other Toyota models that Toyota has a KNOWN problem with. This is a major issue, and puts our safety at risk if the transmission just suddenly goes out. The Toyota dealership has confirmed that we have an issue, and are saying that the transmission MUST be replaced, effectively decommissioning our work commuter vehicle until we can get this sorted. It was diagnosed by a licensed Toyota technician, but it can be inspected by a insurance rep/mechanic upon request. There were no warnings, no lamps, no codes. We just heard the noise, which is seemingly getting worse and louder. Which appeared about 7/15/24. The car has had it's routine maintenance done per the manufacturers specifications. The fluids are routinely checked, and it is taken in to a Toyota dealership for it's servicing, with certified maintenance records. It was never noted on oil changes that this was an issue, or that the transmission fluid was ever an issue. We do not drive this car hard, we do not abuse it. It is our commuter. And now we are looking at having to replace the transmission for essentially the same cost as the car itself.

• STRUCTURE

  The roof of my car started peeling. It’s been progressing quickly. Also starting a small little part in the back as well.

• SUSPENSION

  I own a 2016 Toyota Corolla with 35000 miles. My extended warranty expired in January 2024. In the the last few months my Toyota developed a “rattle” or noise, primarily on the right side at slow speeds and slow turns. I took the car to a well respected and nearby repair facility for an oil change and had them look at the noise. They found that the control arm bushings had stress cracks and the sway bar end links and mount bushings were leaking. I had the repairs done. The defective parts are documented with photos in the electronic version of the repair invoice. The noise came back in a day. The next step would be replacing the struts. The repair shop found no visible wear or damage to the struts. I already spent $2400 on repairs. The noise remains. The damage to the parts most likely started long before the warranty expired in January. I found a Technical Service Bulletin describing the repair for this noise issue. The repair described specifies replacing the control arms. I did that in the above described repair. There are many upset consumers complaining in Internet forums about the same problem in 2014-2019 Toyota Corolla’s. I contacted Toyota customer service by email. They told me there was nothing they could do about the problem since the warranty expired 5 years after purchasing the car. I told them I have an 8 year extended warranty. They insisted that there was no 8 year warranty. I offered to send them proof. I have the same problem as shown below. I replaced the control arms and stabilizer bar links. They appeared to be failing. There are many more pages on the internet with the same problem. I reported this to Toyota. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• STEERING,SUSPENSION

  A knocking noise is coming from the front of car. Noise correlates with car motion. Worn parts in suspension were replaced by Euro Car Doctor in Costa Mesa. One problem complies with Toyota Technical Service Bulletin. Noise continues. The electronic invoice has photos of worn parts. Euro Car Doctor documents concern. I do not trust the local Toyota dealer service department to properly inspect the vehicle.