2020 Toyota Corolla

2020 Toyota Corolla recalls (3)

• FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

  Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

• SEAT BELTS: REAR/OTHER:BUCKLE ASSEMBLY

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 C-HR and 2020 Corolla and Corolla Hybrid vehicles equipped with rear seat belt assemblies with a dual-mode locking mechanism. The seat belt webbing sensor locking mechanism may not lock as intended.

  Remedy: Toyota will notify owners, and dealers will inspect the rear seat belt assembly production dates, and replace the assemblies, as necessary, free of charge. The recall began February 7, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are 19TB22 and 19TA22.

• AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.

  Remedy: Dealers will inspect and replace the sensor as necessary, free of charge. Interim letters notifying owners of the safety risk were mailed in February 2024. Some final remedy owner letters were mailed October 31, 2024. Letters will continue to be mailed in phases through January 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB15/23TA15 Lexus 23LB03/23LA03.

2020 Toyota Corolla safety ratings

Source: NHTSA NCAP ratings.

2020 Toyota Corolla owner complaints (15)

• POWER TRAIN

  The contact owns a 2020 Toyota Corolla. The contact stated that while driving at an undisclosed speed, the clutch failed to operate as intended. The contact stated that the clutch seized, and the RPM increased. No warning lights were illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,330.

• ENGINE

  A message came on the screen saying “engine maintenance required” and it’s not going away. Upon doing a google search, there is a common failure in the cooling system for these cars reported by a lot of owners.

• ELECTRICAL SYSTEM

  The contact purchased a 2020 Toyota Corolla. The contact stated that they discovered a mileage discrepancy after the purchase. The vehicle was a private sale on Facebook market. At the time of purchase, the vehicle mileage was 52,000. It was later discovered that the vehicle’s title mileage was 132,000. The contact stated went the DMV, and he discovered the mileage 132,483.

• UNKNOWN OR OTHER

  Replace Heater Control Valve - Diagnostic code P2681 indicates an internal electrical failure within the heater control valve assembly, a condition commonly seen on Toyota vehicles. Testing showed the electrical portion of the valve is open and no longer maintaining proper circuit continuity, requiring replacement of the heater control valve assembly.

• POWER TRAIN

  "On 04/09/26, I took my vehicle for regular maintenance and an oil change; no potential issues were reported. I operated the vehicle in good faith, trusting its safety. However, on Sunday, 05/03/2026, while driving at highway speeds, the clutch pedal failed and [stuck to the floor / slipped severely]. This caused an immediate loss of power to the wheels in high-speed traffic, creating a life-threatening situation and a high risk of a rear-end collision. No warning lights appeared prior to this failure."

• VISIBILITY/WIPER

  Windshield Wiper Intermittent setting stopped working, and wipers no long return to their home position. This appears to be a common issue with Toyota. When driving in the rain, the wipers will freeze in the up setting, which is very dangerous for it to occur during heavy rain on the highway causing visibility issues. No warnings of any kind given, the wiper switch appears to just go bad, or wear out over time.

• FUEL SYSTEM, GASOLINE,ENGINE

  The contact owns a 2020 Toyota Corolla. The contact stated that while at a red light, the vehicle shut off with the check engine and several other unknown warning lights illuminated. The vehicle restarted after several attempts. The vehicle was taken to an independent mechanic and the failure was duplicated. The mechanic retrieved DTC: P1603; "Engine Stall History" (ECM recording an unexpected engine shutdown or a communication error with the Transmission Control Module (TCM). The mechanic associated the failure with NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline) and referred the contact to the dealer for assistance. Several dealers were contacted, and the contact was informed that the VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 59,000.

• UNKNOWN OR OTHER

  Coolant water control valve short circuit. Causes dealer message that won't clear and dealer wants $600 to replace a $30 part. Part is extremely difficult to get to and should not be a wear item.

• UNKNOWN OR OTHER,ENGINE

  Car shows the below message when A/C is turned on: Engine Maintenance Required Visit Your Dealer

• UNKNOWN OR OTHER

  Message on dashboard that says, "Engine Maintenance Required. Visit Dealer." This message came on at around 31,000 miles and I was told it was three different things all different prices at my dealer. So, I looked into it and found out it was the Coolant Bypass Valve, and asked the dealership about it and they said 700 dollars to replace. I did not want to pay that much especially since I saw online others were having the same problem. Message still pops up to this day when I turn on my A/C. Car now has around 205,000 miles on it and is six years old.

• VISIBILITY/WIPER

  The wipers are turning on randomly by themselves, even when the control switch is set to the “off” position. This has occurred multiple times and happens without any input or activation from me. The issue appears to be intermittent but persistent, and it raises concerns about a potential electrical or control system malfunction.

• POWER TRAIN

  The clutch slave cylinder failed at 48,000 miles. On the freeway, I had difficulty shifting into gear and I had cars passing me at high speeds, putting my life and others' lives at risk. This part defect is due to the plastic clutch slave cylinder failing. This common issue is well-documented by numerous other owners, with the part failing before the routine clutch maintenance cycle. My car was inspected by an independent mechanic, who said the lack of clutch pressure is due to the clutch slave cylinder failing. The worst part is that there were no warning lamps or messages before this happened. Toyota is claiming there is no recalls for this part, whic his astounding because the clutch is essential for the 6speed transmission.

• SERVICE BRAKES

  I am having a problem with my 2020 Toyota Corolla's brakes. I live in [XXX] . In the winter when the car is cold the brakes work normally. When the car has been driven for a while, the car has warmed up, and the brake fluid has thinned, the brakes behave abnormally. When I stop at a red light, after 20 to 40 seconds, the brake pedal slowly drops towards the floor. My understanding is that this could indicate a problem with the master brake cylinder. My fear is that there could be a sudden failure of the cylinder causing an accident. I brought the car to Rudy Luther Toyota in Golden Valley. When I brought the car in, it was warm and the brakes were malfunctioning. Unfortunately, they let the car sit for several hours, the brake fluid cooled, and the mechanic was unable to duplicate the problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER

  when I use blinker windshield wipers turn on and sometimes when I call or somebody calls my cell phone I can hear them, but they cannot hear me. does not happen all the time, but I was concerned since there was a recall on certain toyota corolla that says a short circuit may develop in the OCS sensor, preventing front passenger air bag from deploying and my son who is a mechanic said both of these could be a problem with the wiring in the column and I thought it may be connected to the same recall as the air bags? the wipers coming on is happening more often these days and that is why I mentioned it to my son who is a mechanic. he will not touch it since it is still under my extended protection but he is concerned about it getting worse since the blinker is attached to the column. as far as using not being heard by callers or when I call I am concerned if I need to call in an emergency the ones I call cannot hear me. as far as when this started I do not remember but I know it's been at least 6 months if not longer, it just seems to be doing it more often lately

• VISIBILITY/WIPER

  The windshield wiper switch assembly (column stalk/switch) malfunctions intermittently, sending unintended signals that activate the wipers despite the stalk being firmly in the OFF position. The component is still installed in the vehicle and is available for inspection upon request. Suspected part numbers include 84652-06400 or similar variants. How was your safety or the safety of others put at risk? Sudden, unexpected wiper activation (typically 1-2 wipes, occasionally more) while driving creates a serious distraction and safety hazard. It can startle the driver, cause momentary loss of vehicle control or focus (especially at highway speeds or in traffic), and briefly obstruct vision. This risk is heightened during rain, when wipers are needed but behave erratically, or during acceleration/turns where vibration triggers it—potentially leading to accidents. Has the problem been reproduced or confirmed by a dealer or independent service center? No, the Toyota dealership has not reproduced or confirmed it during short test drives, as the issue is highly intermittent and occurs mainly after warmup from extended driving (20+ minutes), on hot days or after parking off for ~1 hour in heat/vibration. Similar cases reported by other 2020 Corolla owners on Reddit (r/COROLLA) and Toyota Nation forums were eventually diagnosed and fixed by replacing the wiper switch due to worn internal contacts/PCB from heat/vibration. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle was brought to a Toyota dealership, but no detailed inspection or repair occurred due to lack of replication. No inspections by police, insurance, Toyota corporate (manufacturer), or others have taken place. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps, messages, dashboard indicators, or prior symptoms