2024 Toyota RAV4

2024 Toyota RAV4 recalls (3)

• SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024 RAV4 and 2025 Lexus NX vehicles. Some of the bolts that secure the front brake caliper and the wheel hub bearing may be loose, which can result in a damaged caliper brake hose or possible wheel detachment.

  Remedy: Dealers will inspect and tighten the front brake caliper mounting bracket and hub bearing bolts, as necessary, free of charge. In addition, any damaged components will be replaced, free of charge. Owner notification letters were mailed January 23, 2025. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 24TA14 and 24LA08.

• ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.

  Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.

• BACK OVER PREVENTION:DISPLAY FUNCTION

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

  Remedy: Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.

2024 Toyota RAV4 safety ratings

Source: NHTSA NCAP ratings.

2024 Toyota RAV4 owner complaints (15)

• LANE DEPARTURE

  The contact owns a 2024 Toyota RAV4. The contact stated that while driving approximately 55-60 MPH on a freeway, the blind spot monitoring system intermittently failed to detect vehicles in adjacent lanes. The contact stated that the failure nearly resulted in two crashes. There were no warning lights illuminated. The contact continued driving the vehicle to the residence. The vehicle was taken to a dealer within one week for inspection; however, the dealer was unable to duplicate the failure and no repair was performed. The contact stated that the failure recurred, and the vehicle was returned to the dealer, where it remained. The vehicle had not been diagnosed. The manufacturer was notified of the failure; however, no update was provided. The failure mileage was approximately 18,000.

• ELECTRICAL SYSTEM,EQUIPMENT

  The contact owns a 2024 Toyota Rav4. The contact stated that while driving approximately 30 MPH in a neighborhood, an advertisement unexpectedly appeared on the center display and obstructed the navigation screen. The contact stated that on the most recent failure, the navigation screen returned after a short while; however, on a previous occasion, the navigation screen could not be restored without restarting the vehicle. The contact expressed concern that the condition prevented access to the navigation system while driving. The vehicle was taken to a dealer; however, no cause for the failure was found. The vehicle was not repaired. The manufacturer was notified of the failure; however, no response was received. The failure mileage was approximately 17,500.

• STEERING,UNKNOWN OR OTHER,ENGINE

  I was in a drive thru and my car had been idling for less than 5 minutes in the rain and started shuttering really bad with my roms dipping low. i put the vehicle in park and the the entire vehicle shut off and would not stay on without dying. for the next 20 minutes everytime i tried to start it it shut off immediately no matter what i would do. the vehicular kept telling me “Engine Stopped steering power low”. it let me put the vehicle in accessory mode and was fine but my steering wheel remained locked. after about 30 minutes i was able to get the vehicle to start and pull up about 15 feet before it shuttered and i put it in park and it died again. i had to get it towed to the dealership.

• FORWARD COLLISION AVOIDANCE,LANE DEPARTURE

  I purchased a 2024 Toyota RAV4 in March 2024 with the expectation that its advertised safety and driver-assistance systems would function as designed. The vehicle has experienced a failure of the forward camera/ADAS system, resulting in the loss of multiple Toyota Safety Sense features. The following systems are currently unavailable or malfunctioning: • Dynamic Radar Cruise Control / Adaptive Cruise Control • Pre-Collision System • Lane Tracing Assist / Lane Keeping Functions • Road Sign Assist (speed limit recognition) • Related driver-assistance and safety warning functions When cruise control is activated, the vehicle displays a warning that cruise control is unavailable. The dashboard reports multiple safety-system malfunctions. As a result, I have lost essentially all advanced driver-assistance features that were included with the vehicle. Toyota’s dealer diagnosed the failure and Toyota approved the repair under a goodwill case. However, I was informed that the required replacement component is on national backorder with an estimated wait of approximately two months and no guaranteed delivery date. Despite acknowledging the defect and approving repair, Toyota has not provided a comparable loaner vehicle or alternative transportation. I am being asked to continue operating the vehicle for an extended period without the safety technologies that were a significant factor in my purchase decision. I am concerned about the loss of collision-avoidance, lane-assistance, and adaptive-cruise functions, the indefinite repair delay, and the lack of transportation assistance while awaiting parts. I am requesting investigation, assistance, and consideration of repurchase or other appropriate remedies.

• UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE

  Unknown... Car Took off on its own Finally stop Turn car off Would not restart Try again it started Then it not want to move Trying to get it again Damn it car

• UNKNOWN OR OTHER

  The trim around the sunroof is cracked and causing a leak. I took the vehicle to South Hills Toyota in Cannonsburg PA, for maintenance and state inspection, specifically identifying this issue. The car is less than 2 years old still under warranty Initially I was told it was not a material defect and not covered by warranty, remedy would be replacement of entire sunroof. Discussion with the service manager resulted in the defect being escalated to Toyota. Pictures were taken by the Toyota service team and sent to Toyota for further review.

• UNKNOWN OR OTHER

  I apologize if this does not meet the NHTSA bar of a safety hazard. It does reduce the ability for hands free navigation and acts as a distraction for drivers. Toyota Rav4s have very poor GPS tracking which makes the directions in the integrated head unit and guage cluster very distracting because they are consistently incorrect. There are dozens, maybe 100+, reports online of people having similar issues. Toyota dealership has looked at it many times, escalated for troubleshooting, and as of today they say there is no fix. I have many videos to demonstrate the issue is not a fluke. There are no warning signs and the GPS will just start giving poor directions. The "danger" is in the fact that the only workaround now is to engage with a phone or other device while driving. In theory a human can rise above this and be smarter than the car but isn't that true of many safety components like non-functioning wipers(drive slow) or blind spot protectiong(check your mirror). The car is giving bad directions that the user is relying on as a navigational aid.

• STEERING

  2024 RAV4 XLE Premium will randomly pull to the left or right after start-up, or cold soak, and has been doing so since new. The Dealer has verified that the alignment is correct and there are no mechanical issues. When the vehicle is shut off and restarted, the symptoms will likely change and will often correct itself, but this sometimes changes the direction of the pull. This aligns with the same symptoms as NHTSA MC‑10214321 and Toyota Tech Tip T‑TT‑0616‑20. I have shared this information with the Dealer and they claim to be investigating the possible cause and I am waiting on confirmation of next steps to resolve it. Please update the known NHTSA complaint that has already been issued for Toyota RAV4 model years 2019-2021 to include later model years and including 2024.

• ENGINE

  After driving my 2024 RAV4 in rain for about an hour, I was then parked for about 5 minutes in a parking garage and the engine shut down and warning light came on for power steering, and white smoke /steam came out of the engine. Engine would not restart, even after tow truck arrived thirty minutes later. Once dealership received my vehicle they say it starts fine and can't find any issues. They have been unable to duplicate the issue. I saw this same issue online and have requested they check the MAF sensor and the battery load test. Seems to be a big issue in these cars.

• LATCHES/LOCKS/LINKAGES

  While driving on the freeway for about 60 minutes, the drivers, driver side door that was locked released and opened up. The door was fully shut and no warning door ajar was lit up before driving. I grabbed the door and held it until I could exit and slow down to shut it. I tried to fully pull it shut while driving but was unsuccessful. I slowed down and had to pull the handle to release the lock and open the door more to have enough momentum to fully close the door again.

• VISIBILITY

  The contact owns a 2024 Toyota Rav4. The contact stated that while his wife was driving 75 MPH, as an occupant seated in the passenger’s side seat, the contact became aware that the rear passenger’s side window shattered without impact. Neither the dealer nor an independent mechanic was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 18,000.

• VISIBILITY/WIPER

  Driving on [XXX] merging onto [XXX] heading north, the sun roof exploded at approximately 70 mph. There were not vehicles near us at the time nor any obvious shrapnel or ricochet marks indicating an object struck the glass causing the break. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

• ELECTRICAL SYSTEM

  The contact owns a 2024 Toyota Rav4. The contact stated that on several occasions while attempting to start the vehicle, the message to "Place Key fob Next to Start Button" was displayed. The contact placed the key fob on the start button, and the vehicle started. While driving approximately 35 MPH, the vehicle stalled. The vehicle was pulled over to the side of the road. The contact pressed the start button, but the vehicle failed to restart. The contact stated that the message was displayed again, and the key fob was placed next to the start button, and the vehicle restarted. The dealer was contacted and advised to change the battery in the key fob. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 11,000.

• STRUCTURE

  I was driving down the Interstate and my sunroof exploded without apparent cause. This was in Colorado, and there was a change in altitude, so I thought perhaps a difference in pressure might have played a part. There were no cars in front of me nor any visible debris. I was just driving, and heard a loud bang over my head. My sunroof and shade were closed at the time.

• STEERING,WHEELS,UNKNOWN OR OTHER

  Car is out of alignment resolutions in the rear passenger tire to wear down at an abnormal rate. Had the vehicle inspected by a local mechanic and two different dealerships. All three inspections came back with the same answer. The camber and the toe for the right rear tire can not be set to a center good alignment. Leaving it in the red zone that will result in excessive Tire wear, handling and safety problems.